ToyotaTundra2002V8/toyota/tundra/2002/v8/

2002 Toyota Tundra — V8

Factory specifications, fluid capacities, torque values, EPA fuel economy and the federal safety record for the 2002 Tundra V8.

Body TRUCKEngine V8Transmission Automatic 4-spd

The 2002 Toyota Tundra is a V8 truck paired with an automatic 4-speed transmission, requiring 5.5 quarts of 5W-30 API oil and carrying EPA ratings of 13/17/15 mpg. Toyota recorded 511 owner complaints for this model year, with structure identified as the top complaint area and six recalls issued. Across the 1999–2026 model range, that total sits well above the 1999 baseline of one complaint yet below the 2000 peak of 1,032, marking the 2002 model as an early-generation year that drew measurable reliability attention without representing the line's worst showing.

Model year201120102009200820072006200520042002

Quick specs

Fluid capacities, tune-up values and fuel economy at a glance.

Engine oil capacity5.5 qtOEM · verified
Engine oil type5W-30 APIOEM · verified
Lug nut torque83 ft-lbsOEM · verified
EPA fuel economy13/17/15 mpgEPA · verified

Fitment & sizes

Replacement part sizes and factory part numbers — battery, bulbs, filters and belts.

From the factory this vehicle uses a BCI 24F Primary Battery · 585 Primary Battery CCA battery, OE oil filter 90915YZZD1. Each part links to every other vehicle that shares it, so a part you already stock may fit more of your fleet than you'd expect.

Battery groupBCI 24F Primary Battery · 585 Primary Battery CCAOEM · verified
Tail / brake / turnOFFOEM · verified

OE service part numbers OEM · verified

Engine oil filter90915YZZD1 alt 90915YZZD3
Engine air filter1780107010
Fuel filter2303062010
Spark plug9091901166
Front wiper blades852120C012 alt 852220C012
Serpentine belt9008091090 alt 9936481070
Thermostat9091603075 alt 9091603100

Full specifications

Engine, drivetrain, dimensions and economy.

Engine & drivetrain NHTSA vPIC

TransmissionAutomatic 4-spd

Dimensions & weight NHTSA vPIC

Overall length213 in
Overall width75.2 in
Overall height71.3 in
Wheelbase128.3 in
Curb weight4299 lb
Track (front / rear)66.1 / 65 in
Weight distribution (front / rear)57/43

Ratings & economy EPA / vPIC

EPA city / highway / combined13 / 17 / 15 mpg
DrivetrainRear-Wheel Drive
Recommended fuelRegular Gasoline

Performance & power Independent road tests

0–60 mph, quarter-mile, horsepower and torque from independent road tests.

No 2002 road test on record; the results below are same-engine tests from nearby model years, each shown under its own year.

8.2–9.2 sec0–60 mph (tested)quickest 8.20 sec — 2000 SR5 Access Cab (6.2 ft. Bed)
315 lb-ftTorque (as tested)
YearTrim / engine0–60¼ mileHPDrivetrain
2000SR5 Access Cab (6.2 ft. Bed) 4.7L V88.20 sec16.30 sec245 hpRWD
2000SR5 Access Cab (6.2 ft. Bed) 4.7L V88.50 sec16.60 sec245 hp4x4
2004Limited Double Cab (6.2 ft. Bed) 4.7L V88.80 sec16.80 sec240 hp4x4
2004Limited Double Cab (6.2 ft. Bed) 4.7L V89.20 sec17.20 sec240 hp4x4

Service quick specs OEM factory data

Capacities, torques and tune-up values from the factory service manual.

This engine holds 5.5 qt of 5W-30 API engine oil, 75W-90 · GL-5 in the differential, DOT 3 brake fluid. Torque lug nuts to 83 ft-lbs. The firing order is 1-8-4-3-6-5-7-2.

Lubricants & capacities

Brake FluidDOT 3
Differential Gear Oil75W-90 · GL-5
Differential Gear Oil Capacity2.5 Pints
Engine Oil5W-30 · API
Engine Oil Capacity5.5 qt
Engine Oil5W-30 · API
Engine Oil Capacity6.5 qt
Transfer Case Fluid75W-90 · GL-4 · GL-5

Engine torques

Crankshaft Pulley and/or Damper Bolts184 ft-lbs
Crankshaft Pulley and/or Damper Bolts181 ft-lbs
Oil Pump to Cylinder BLock Bolts/Studs14MM

Chassis torques

Leaf Spring to Axle (U-bolts)98.0 ft-lbs
Leaf Spring to Chassis Bracket125.0 ft-lbs
Leaf Spring to Rear Shackle125.0 ft-lbs
Leaf Spring Rear Shackle to Chassis Bracket125.0 ft-lbs
Lug Nuts83 ft-lbs
Transfer Case Fill Plug36.0 ft-lbs
Transfer Case Drain Plug36.0 ft-lbs
Front Wheel Hub159 ft-lbs

Ignition

Cylinder Firing Order1-8-4-3-6-5-7-2
Curb Idle Speed (No Load)700 rpm
Curb Idle Speed Variance (No Load)50 rpm
Curb Idle Speed (No Load)700 rpm
Curb Idle Speed Variance (No Load)50 rpm
Spark Plug ManufacturerDenso
Spark Plug Gap0.043 in
Spark Plug Torque13 ft-lbs

Battery & A/C

RefrigerantR134a
Refrigerant Capacity1.32 lbs
Oil GroupPAG
Oil Type46
Standard BCI Group Number24F Primary Battery
Standard BCI Cranking Performance585 Primary Battery cca

Service checks

Injector Primary Resistance13.4-14.2 @ 68 degreesF ohms
Engine Compression145-174 psi
Engine Compression142-192 psi

Brakes

Torque to Knuckle90 ft-lbs
Minimum Pad ThicknessFront: 0.039; Rear: 0.039 in
Minimum Shoe Thickness0.039 in
Rotor Runout Limit0.0028 in
Rotor Nominal Thickness From1.102 in
Rotor Nominal Thickness To1.102 in
Rotor Discard at or Under1.024 in
Drum Nominal Diameter11.614 in

Multi-step torque procedures OEM · verified

Connecting Rod (Large End) Bearings — tightening sequence 1 stages
118 ft. lbs., Step 2: 9018 ft. lbs
Engine Flywheel Bolts — tightening sequence 1 stages
136 ft. lbs., Step 2: 9036 ft. lbs
Main Bearings — tightening sequence 1 stages
120 ft. lbs., Step 2: 9020 ft. lbs

Factory maintenance schedule OEM · verified

Normal service, condensed from the factory interval matrix.

Under the factory schedule, replace the engine oil and filter every 7,500 mi; coolant every 30,000 mi. The big-interval services (every 30,000 mi for coolant, and the transmission fluid) are the ones owners most often skip — on a lower-mileage example, assume the original fluids are still in it and check them first.

Every 7,500 miEngine Oil (drain & refill) · Engine Oil Filter (replace) · Tire & Wheel Assembly (rotate)
Every 15,000 miAccessory Drive Belt (inspect) · Brake Drum Assembly (inspect) · Brake System (inspect) · CV Joint Boot (inspect) · Differential (inspect fluid level) · Driveshaft (inspect)
Every 30,000 miEngine Air Filter Element (replace) · Engine Coolant System (drain, flush & refill) · Fuel Evaporative Emission Control System Lines (inspect) · Fuel Line (inspect) · Fuel Tank (inspect) · Fuel Tank Filler Cap O-Ring (inspect)
At 60,000 miAccessory Drive Belt (inspect)
Every 60,000 miEngine Valves (inspect valve lash)
Every 90,000 miTiming Belt (replace)

Reliability & federal safety record

Owner-reported issues, recalls, investigations and service bulletins on record with NHTSA — an unfiltered look at what owners actually experience.

The 2002 model year records 511 federal complaints, representing an increase from the 420 reported in 2001 but remaining well below the 2000 volume of 1032. Recall activity held steady at six units compared to the previous year, yet federal investigations rose to three, continuing an upward trend that would reach six investigations by 2004. Top complaint areas for this specific year include Structure with 113 reports and Service Brakes, Hydraulic with 86, though the provided data does not specify the root causes for these failures. Within the provided record, the 2002 model avoids the highest complaint peaks seen in 2000 and 2006 but exhibits higher issue volume than the subsequent 2003 model year. Consequently, while not the most problematic year of the period, the elevated investigation count and structural complaints suggest buyers should proceed with caution rather than viewing this as the optimal model year to purchase.

6
Open recalls
NHTSA campaigns
132
Service bulletins
Manufacturer communications
3
ODI investigations
Office of Defects Investigation
511
Owner complaints
33 involved a crash · 1 a fire
NHTSA crash-test rating federal NCAP · out of 5 stars
Rollover★★★★★

Owner complaints filed with NHTSA, by component

All 511 complaints on record, top 8 components.

Structure113
Service Brakes, Hydraulic86
Suspension54
Power Train33
Unknown Or Other22
Air Bags20
Steering17
Tires10

Source: NHTSA Office of Defects Investigation complaint database.

Recalls NHTSA · verified

Showing 2 of 6 campaigns on record for this vehicle.

09E025000Exterior Lighting:HeadlightsReported 11/05/2009

DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE… Remedy: DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT…

09V444000Structure:Frame And Members:Underbody ShieldsReported 18/11/2009

TOYOTA IS RECALLING MODEL YEAR 2000-2003 TUNDRA VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE FOLLOWING STATES: CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN… Remedy: TOYOTA IS ASKING OWNERS OF THE AFFECTED VEHICLES TO REMOVE THE SPARE TIRE FROM UNDER THE VEHICLE UNTIL A REMEDY CAN BE OBTAINED. DEALERS WILL INSPECT THE REAR CROSS MEMBER AND…

Technical service bulletins NHTSA · verified

Showing 5 of 132 bulletins on record with NHTSA.

BulletinDateComponentSummary
T-SB-0035-24 Rev22024-12-06StructureAcid rain results from rainwater or other airborne moisture that become acidic due to…
T-SB-0038-24 Rev22024-12-06StructureTo prevent brake rotor rust from forming during transportation and storage, wheel film…
T-SB-0039-24 Rev22024-12-06StructureThe condition known as acid rain is caused by airborne chemicals or particles in the…
T-SB-0061-23 Rev22024-12-05StructureToyota vehicles are currently protected with RapgardTM protective film designed to…
T-SB-0062-23 Rev22024-12-03StructureVehicles may occasionally be subjected to contamination by airborne iron particles shed…

Common OBD-II trouble codes

The most common OBD-II codes for this vehicle's emissions system. These are standardized SAE J2012 definitions, not vehicle-specific fault reports.

P0420
Catalyst system efficiency below threshold — Bank 1
P0300
Random / multiple cylinder misfire detected
P0171
System too lean — Bank 1
P0455
Evaporative emission system leak detected — large leak
P0128
Coolant thermostat below regulating temperature
P0442
Evaporative emission system leak detected — small leak

VIN tools

Decode factory build data for a specific vehicle by VIN.

VIN
Decode a VIN to confirm the transmission and build data for a specific Tundra. OEM
Build data
Plant, GVWR class, engine and body data for any 17-character VIN.
Recalls
Check open recall campaigns against a specific vehicle by VIN.

Vehicles with shared specs

Find every vehicle that shares this one's battery, bulbs, oil capacity, platform or parts.

Reference guides

Cross-vehicle references for the kinds of data on this page.

Frequently asked

How much oil does the 2002 Tundra V8 take?

5.5 qt of 5W-30 API, per the factory manual.

Does the 2002 Tundra have open recalls?

NHTSA lists 6 recall campaign(s) for this model year. Check your specific vehicle by VIN.

What gas mileage does the V8 get?

EPA figures are 13 city / 17 highway / 15 combined mpg.