Factory specifications, fluid capacities, torque values, EPA fuel economy and the federal safety record for the 2016 Challenger 6.4L. Covers both the standard and High Output 6.4L.
The 2016 Dodge Challenger 6.4L sits on the LA platform as a passenger car whose 6.4-liter engine is paired with an eight-speed automatic and rated by the EPA at 15 mpg city, 25 mpg highway, and 18 mpg combined — figures that underscore the trade-offs of its larger displacement. That pairing places the model among the more substantial entries in the Challenger catalog of its era, and the fuel-economy numbers quantify what buyers accept in exchange. Set against the model's 2008–2023 complaint record, which runs from a peak of 298 reports in 2010 to a low of 9 in 2022, the 2016's 78 owner complaints — with the power train as the leading category and two recalls on file — sit comfortably in the quieter middle of that range, marking it as a comparatively stable year rather than a high-risk outlier.
Fluid capacities, tune-up values and fuel economy at a glance.
Replacement part sizes and factory part numbers — battery, bulbs, filters and belts.
From the factory this vehicle uses a BCI 94R · 730 CCA battery, OE oil filter 04884899AC. Each part links to every other vehicle that shares it, so a part you already stock may fit more of your fleet than you'd expect.
| Engine oil filter | 04884899AC alt 04892339BE |
| Engine air filter | 04861746AB alt 68172459AA |
| Spark plug | SP149212AC alt SP143877AB |
| Battery | BBH7F001AA |
| Front wiper blades | 68015148AA |
| Thermostat | 52028898AJ alt 05184894AA |
| Cabin air filter | 68535614AA |
Engine, drivetrain, dimensions and economy.
| Transmission | Automatic 8-spd |
| Overall length | 197.6 in |
| Overall width | 75.6 in |
| Overall height | 57.1 in |
| Wheelbase | 116.1 in |
| Curb weight | 4169 lb |
| Track (front / rear) | 63 / 63.8 in |
| Weight distribution (front / rear) | 56/44 |
| EPA city / highway / combined | 15 / 25 / 18 mpg |
| Drivetrain | Rear-Wheel Drive |
| Recommended fuel | Premium Gasoline |
0–60 mph, quarter-mile, horsepower and torque from independent road tests.
No 2016 road test on record; the results below are same-engine tests from nearby model years, each shown under its own year.
| Year | Trim / engine | 0–60 | ¼ mile | HP | Drivetrain |
|---|---|---|---|---|---|
| 2015 | R/T Scat Pack 6.4 Coupe 6.4L V8 | 4.20 sec | 12.60 sec | 485 hp | RWD |
| 2015 | R/T Scat Pack 6.4 Coupe 6.4L V8 | 4.20 sec | 12.60 sec | 485 hp | RWD |
| 2015 | R/T Scat Pack 6.4 Coupe 6.4L V8 | 4.40 sec | 12.90 sec | 485 hp | RWD |
| 2015 | SRT 392 Coupe 6.4L V8 | 4.70 sec | 12.80 sec | 485 hp | RWD |
| 2017 | T/A 392 Coupe 6.4L V8 | 4.20 sec | 12.50 sec | 485 hp | RWD |
| 2011 | SRT8 392 Coupe 6.4L V8 | 4.50 sec | 12.90 sec | 470 hp | RWD |
| 2011 | SRT8 392 Coupe 6.4L V8 | 4.50 sec | 12.90 sec | 470 hp | RWD |
| 2011 | SRT8 392 Coupe 6.4L V8 | 4.60 sec | 13.00 sec | 470 hp | RWD |
Capacities, torques and tune-up values from the factory service manual.
This engine Synthetic · SAE 75W85 · API · GL-5 · SAE 75W85 · SAE 75W85 in the differential, DOT 3 · SAE J1703 brake fluid. The firing order is 1-8-4-3-6-5-7-2.
| Automatic Transmission Fluid | ATF+4 |
| Automatic Transmission Fluid Capacity | 4.0-6.0 |
| Brake Fluid | DOT 3 · SAE J1703 |
| Clutch Fluid | DOT 3 · SAE J1703 |
| Differential Gear Oil | Synthetic · SAE 75W85 · API · GL-5 · SAE 75W85 · SAE 75W85 |
| Differential Gear Oil Capacity | 195 Rear Axle |
| Engine Coolant | MS-12106 |
| Engine Coolant Capacity | 11.1 qt |
| Exhaust Manifold to Cylinder Head Bolts | 17 |
| Intake Manifold to Engine Bolts | 8.8 |
| Exhaust Manifold to Cylinder Head Bolts | 23 |
| Intake Manifold to Engine Bolts | 8.8 |
| Exhaust Manifold to Cylinder Head Bolts | 22 |
| Intake Manifold to Engine Bolts | 8.8 |
| Exhaust Manifold to Cylinder Head Bolts | 22 |
| Intake Manifold to Engine Bolts | 8.8 |
| Driveshaft Flange to Transmission | 72.0 ft-lbs |
| Rear Wheel Hub | 170 ft-lbs |
| Rear Wheel Hub Bearing Housing Bolts | INSTALL A NEW HUB NUT. ft-lbs |
| Cylinder Firing Order | 1-2-3-4-5-6 |
| Cylinder Firing Order | 1-8-4-3-6-5-7-2 |
| Ignition Coil Primary Resistance | 0.6-0.9 ohms |
| Ignition Coil Secondary Resistance | 6,000-9,000 ohms |
| Spark Plug Manufacturer | Mopar |
| Spark Plug Gap | .043 in |
| Standard BCI Group Number | 94R |
| Standard BCI Cranking Performance | 730 cca |
| Pressure Test | 15 psi |
| Radiator Cap Pressure Relief | 16-21 psi |
| Thermostat Opening Temperature | 195 °F |
| Regulated Fuel System Pressure (With Vacuum) | 58+/-5 psi |
| Regulated Fuel System Pressure (With Vacuum) | 56-60 psi |
| Engine Compression | 100 min psi |
| Engine Compression | All gasoline 100 psi / Max Variation 1 psi |
| Brake Caliper Bolt to Carrier Torque | Front: 44; Rear: 43 /; Front: 44; Rear: 23 |
| Brake Caliper Carrier to Hub Bolt Torque | Front: 121; Rear: 98 /; Front: 98; Rear: 81 |
| ABS Sensor Torque | 8.5 / NS |
| Minimum Pad Thickness | Front: 0.040; Rear: 0.040 in |
| Vented Rotor Minimum Thickness after Refinish | Front: 1.040; Rear: 17; Rear: 18 |
| Variation from Parallelism Thickness Variation | .0004 |
| Maximum Rotor Runout | .0014 When measured on vehicle |
| 1 | 90 | |
| 1 | 30 ft. lbs., step 2: 105 | 30 ft. lbs |
Condensed service procedures for routine maintenance. Procedures that require dealer diagnostic equipment are identified and summarized only.
| Tool required | DRBIII scan tool (dealer / locksmith) |
| Why | Transmitter codes are written into the receiver in the passenger door module |
| When needed | After Sentry Key Immobilizer Module (SKIM) replacement |
| Tool required | DRBIII scan tool |
| Also required | The vehicle's four-digit PIN code |
Owner-reported issues, recalls, investigations and service bulletins on record with NHTSA — an unfiltered look at what owners actually experience.
In the Challenger generation, the 2016 model sits near the low‑point of the complaint curve, with only 78 complaints versus a peak of 298 in 2010 and a gradual decline to 9 by 2022. Recall activity also reaches a trough in 2016 (2 recalls), markedly fewer than the 5‑7 recalls typical from 2009‑2015 and only slightly above the single‑recall years after 2020. Technical Service Bulletins remain relatively high (278) but follow the overall pattern of a gradual reduction from the 350‑plus seen in 2015. The top complaint categories for 2016 are Power Train (10), Engine (9), Unknown/Other (8) and Electrical System (7), with modest crash (10) and fire (2) reports. This downward trend in complaints and recalls suggests that 2016 is a comparatively reliable year within the generation, making it a solid choice for a used purchase.
All 78 complaints on record, top 8 components.
Source: NHTSA Office of Defects Investigation complaint database.
Showing 2 of 2 campaigns on record for this vehicle.
Chrysler (FCA US LLC) is recalling certain Mopar Stage 1 Kit Performance Packages Powertrain Control Modules (PCM) Part Numbers P5160023, P5160025, and Demon Crate PCM Part Number 68412287AA. The PCMs are being recalled… Remedy: Chrysler will notify owners, and dealers will either perform a software update or replace the PCM, free of charge. The recall began July 26 , 2018. Owners may contact Chrysler…
Chrysler (FCA US LLC) is recalling certain 2014-2018 Dodge Journey, Charger and Durango, RAM 2500, 3500, 3500 Cab Chassis (more than 10,000lb), 4500 Cab Chassis and 5500 Cab Chassis, Jeep Cherokee and Grand Cherokee and… Remedy: Chrysler will notify owners, and dealers will inspect the software, and perform a software flash on the engine or powertrain control module, free of charge. The recall began June…
Showing 5 of 278 bulletins on record with NHTSA.
| Bulletin | Date | Component | Summary |
|---|---|---|---|
| S2621000003 REV.A | 2026-03-09 | Power Train | The vehicle will exhibit a service transmission/check engine warning indicator for the… |
| S2608000010 | 2026-03-05 | Electrical System | Active Diagnostic Trouble Code (DTC) B1A10-00, B1A11-00, B1A12- 00, B1A13-00-, B1A14-00… |
| 108463 | 2025-11-18 | Service Brakes | PAD KIT - REAR DISC BRAKE, FRONT DISC BRAKE |
| 108464 | 2025-11-17 | Service Brakes | PAD KIT - REAR DISC BRAKE, FRONT DISC BRAKE |
| 31-001-25 REV. B | 2025-08-16 | Structure | Aluminum Body Panel Corrosion Repair Aluminum corrosion or bubbling along the leading… |
The most common OBD-II codes for this vehicle's emissions system. These are standardized SAE J2012 definitions, not vehicle-specific fault reports.
Decode factory build data for a specific vehicle by VIN.
Find every vehicle that shares this one's battery, bulbs, oil capacity, platform or parts.
Cross-vehicle references for the kinds of data on this page.
NHTSA lists 2 recall campaign(s) for this model year. Check your specific vehicle by VIN.
EPA figures are 15 city / 25 highway / 18 combined mpg.