VolvoXC602020Overview/volvo/xc60/2020/base/

2020 Volvo XC60

Factory specifications, fluid capacities, torque values, EPA fuel economy and the federal safety record for the 2020 XC60.

Transmission Automatic (S8)

The 2020 Volvo XC60 is equipped with an automatic (S8) transmission and EPA-rated fuel economy of 20/27/23 mpg, while its reliability record shows 20 owner complaints and six recalls, with the electrical system generating the most complaints. Set against the 2009–2017 model years, which saw complaint volumes reach a high of 66 in 2013 and a low of 14 in 2017, the 2020 model sits near the lower end of that historical band. That positioning suggests the XC60 largely maintained the reduced complaint trend observed by 2017 rather than returning to the higher levels seen earlier in that period.

Model year202620252024202320222021202020192018

Quick specs

Fluid capacities, tune-up values and fuel economy at a glance.

Lug nut torque103 ft-lbsOEM · verified
EPA fuel economy20/27/23 mpgEPA · verified

Fitment & sizes

Replacement part sizes and factory part numbers — battery, bulbs, filters and belts.

From the factory this vehicle uses OE oil filter 32140029. Each part links to every other vehicle that shares it, so a part you already stock may fit more of your fleet than you'd expect.

Tire size235/55R19/XL 105VOEM · verified
Wheel / rim7.5; Optional: 8 inOEM · verified

OE service part numbers OEM · verified

Engine oil filter32140029 alt 32257032
Engine air filter31370089
Fuel filter32242191
Battery31652067 alt 31652065
Front wiper blades31490718 alt 31490720
Thermostat31368063 alt 31686046
Cabin air filter31407747 alt 31434971

Full specifications

Engine, drivetrain, dimensions and economy.

Engine & drivetrain NHTSA vPIC

TransmissionAutomatic (S8)

Dimensions & weight NHTSA vPIC

Overall length184.6 in
Overall width74.8 in
Overall height65.4 in
Wheelbase113 in
Curb weight4114 lb
Track (front / rear)65.4 / 65.4 in
Weight distribution (front / rear)55/45

Ratings & economy EPA / vPIC

EPA city / highway / combined20 / 27 / 23 mpg
DrivetrainAll-Wheel Drive
Passenger volume103 cu ft
Cargo volume30 cu ft
Recommended fuelPremium Gasoline

Performance & power Independent road tests

0–60 mph, quarter-mile, horsepower and torque from independent road tests.

Independent road tests for the XC60 of this era, listed by trim and engine — this page spans more than one engine, so no single horsepower figure is shown.

4.3–7.3 sec0–60 mph (tested)quickest 4.30 sec — 2023 Recharge T8 Ultimate Dark
YearTrim / engine0–60¼ mileHPDrivetrain
2019T6 R-Design 2.0L Turbo Supercharger I-45.40 sec14.00 sec316 hpAWD
2019T5 Momentum 2.0L Turbo I-46.50 sec15.20 sec250 hpAWD
2021Recharge T8 Inscription 2.0L Turbo Supercharger I-4 + Elec5.00 sec13.60 sec400 hpAWD
2018T8 e Inscription Plug-in Hybrid 2.0L Turbo Supercharger I-4 + Elec 10.4-kWh5.10 sec13.70 sec400 hpAWD
2018T8 e Inscription Plug-in Hybrid 2.0L Turbo Supercharger I-4 + Elec 10.4-kWh5.40 sec14.00 sec400 hpAWD
2018T8 e Inscription Plug-in Hybrid 2.0L Turbo Supercharger I-4 + Elec 10.4-kWh5.40 sec13.90 sec400 hpAWD
2018T6 Inscription 2.0L Turbo Supercharger I-46.10 sec14.60 sec316 hpAWD
2018T5 Momentum 2.0L Turbo I-46.20 sec14.70 sec250 hpAWD

Service quick specs OEM factory data

Capacities, torques and tune-up values from the factory service manual.

Torque lug nuts to 103 ft-lbs.

Engine torques

Camshaft Bearing/Carrier Cap Bolts or Studs13.0 ft-lbs

Chassis torques

Lug Nuts103 ft-lbs
Lug Nuts103 ft-lbs

Battery & A/C

RefrigerantR1234yf
Refrigerant Capacity1.43 lbs
Oil GroupPAG
Oil Type46YF
Oil Capacity4.40 oz

Brakes

Brake Caliper Bolt to Carrier TorqueFront: 42.0 ft-lbs; Rear: 21.0 ft-lbs
Brake Caliper Carrier to Hub Bolt TorqueFront: 148.0 ft-lbs
ABS Sensor TorqueFront: 6.0; Rear: 6.0
Vented Rotor Minimum Thickness for ReplacementRear: .689
Vented Rotor Minimum Thickness after RefinishFront: NS, Rear: .740
Maximum Rotor RunoutFront: .0016; Rear: .003

Multi-step torque procedures OEM · verified

Connecting Rod (Large End) Bearings — tightening sequence 1 stages
111.0 ft. lbs., Step 2: 18.0 ft. lbs., Step 3: 90°11 ft. lbs
Cylinder Head — tightening sequence 1 stages
129.5 ft. lbs., Step 2: 120°, Step 3: 120°29.5 ft. lbs
Engine Flywheel Bolts — tightening sequence 1 stages
133.0 ft. lbs., Step 2: 50°33 ft. lbs
Main Bearings — tightening sequence 1 stages
1Inside Bolts15 ft.lbs

Factory maintenance schedule OEM · verified

Normal service, condensed from the factory interval matrix.

Under the factory schedule, replace the engine oil and filter every 10,000 mi; spark plugs every 60,000 mi; coolant every 10,000 mi. The big-interval services (every 10,000 mi for coolant, and the transmission fluid) are the ones owners most often skip — on a lower-mileage example, assume the original fluids are still in it and check them first.

Every 10,000 miBrake Linings (inspect) · Brake Rotor (inspect) · Engine Coolant System (inspect fluid level) · Engine Oil (drain & refill) · Engine Oil Filter (replace) · Exterior Lighting (inspect)
Every 20,000 miCabin Air Filter (replace) · Engine Assembly (leak inspection) · Foglamp (adjust alignment) · Headlamp (inspect alignment)
Every 40,000 miBrake Hydraulic System (drain, refill & bleed) · Brake Line (inspect) · CV Joint Boot (inspect) · Drive Axle Assembly (inspect) · Driveshaft (inspect) · Driveshaft U-Joint (inspect)
Every 50,000 miTransmission Assembly (inspect fluid level)
Every 60,000 miSpark Plugs (replace)
At 150,000 miDrive Belt (replace) · Timing Belt Tensioner (replace)

Reliability & federal safety record

Owner-reported issues, recalls, investigations and service bulletins on record with NHTSA — an unfiltered look at what owners actually experience.

The provided federal record establishes a historical baseline from 2009 to 2017, where annual complaints fluctuated between 0 and 66, recalls ranged from 1 to 7, and Technical Service Bulletins spanned from 27 to 353. For the 2020 model year, the available data highlights specific complaints including 3 in the Electrical System, 2 in Service Brakes, 2 in Unknown Or Other, and 2 in the Engine. This specific distribution is accompanied by zero recorded crash or fire complaints, indicating no reported safety-critical failures in these categories. While the historical trend from 2009 to 2017 shows complaint volumes reaching as high as 66, the 2020 figures appear modest in comparison to those peak years. Direct comparison to immediate successor years is constrained because the provided year-by-year record concludes in 2017, leaving the later trend arc incomplete. Consequently, the 2020 XC60 represents a statistically sound choice for buyers seeking a model year with minimal reported federal complaints.

6
Open recalls
NHTSA campaigns
246
Service bulletins
Manufacturer communications
1
ODI investigations
Office of Defects Investigation
20
Owner complaints
0 involved a crash · 0 a fire
NHTSA crash-test rating federal NCAP · out of 5 stars
Overall★★★★★
Frontal★★★★★
Side★★★★★
Rollover★★★★
Owner complaints by model year NHTSA · this generation & adjacent

Owner complaints filed with NHTSA, by component

All 20 complaints on record, top 8 components.

Electrical System3
Service Brakes2
Unknown Or Other2
Engine2
Electrical System,Service Brakes2
Electrical System,Structure1
Wheels1
Power Train,Wheels1

Source: NHTSA Office of Defects Investigation complaint database.

Recalls NHTSA · verified

No recall campaigns on record with NHTSA for this vehicle as of the last data refresh.

Technical service bulletins NHTSA · verified

Showing 5 of 246 bulletins on record with NHTSA.

BulletinDateComponentSummary
33031.6.02026-05-23Unknown Or OtherThis is a Technical Journal: Text plus 1 .jpg attachment - If remote control key is not…
34521.11.12026-05-07Exterior LightingThis is a Technical Journal: Headlamp condensation inside lens - information/leak test…
36496.10.02026-05-07Power TrainThis is a Technical Journal: Intermittent knocking noise during acceleration. If the…
35503.4.02026-05-06StructureThis is a Technical Journal: Panoramic sunroof, sealing strip has a gap
35526.1.82026-04-23EngineThis is a Technical Journal: Text plus 2 PDFs and 1 .PNG Oil Consumption test. Perform…

Common OBD-II trouble codes

The most common OBD-II codes for this vehicle's emissions system. These are standardized SAE J2012 definitions, not vehicle-specific fault reports.

P0420
Catalyst system efficiency below threshold — Bank 1
P0300
Random / multiple cylinder misfire detected
P0171
System too lean — Bank 1
P0455
Evaporative emission system leak detected — large leak
P0128
Coolant thermostat below regulating temperature
P0442
Evaporative emission system leak detected — small leak

VIN tools

Decode factory build data for a specific vehicle by VIN.

VIN
Decode a VIN to confirm the transmission and build data for a specific XC60. OEM
Build data
Plant, GVWR class, engine and body data for any 17-character VIN.
Recalls
Check open recall campaigns against a specific vehicle by VIN.

Vehicles with shared specs

Find every vehicle that shares this one's battery, bulbs, oil capacity, platform or parts.

Reference guides

Cross-vehicle references for the kinds of data on this page.

Frequently asked

Does the 2020 XC60 have open recalls?

NHTSA lists 6 recall campaign(s) for this model year. Check your specific vehicle by VIN.

What gas mileage does the XC60 get?

EPA figures are 20 city / 27 highway / 23 combined mpg.