Volvo›S80›2007›Overview/volvo/s80/2007/base/

2007 Volvo S80

Factory specifications, fluid capacities, torque values, EPA fuel economy and the federal safety record for the 2007 S80.

Body PASSENGER CAR

The 2007 Volvo S80 is a passenger car whose engine calls for 7.4 quarts of 5W-30 or 10W-30 API-rated oil, the kind of mature, conservative specification typical of a manufacturer refining an established model line. Within the S80's complaint record spanning 1999 through 2016, the 2007 model year registers 24 owner reports — led by structural issues — alongside five recalls, a notably calmer profile than the 345-complaint peak recorded in 2000. That places the 2007 S80 as a relatively settled data point in the model's history, offering researchers a clear contrast to both the early-decade turbulence and the near-silent 2014 model year that logged just a single complaint. Even so, the concentration of structural complaints and the recall count keep this year from serving as a clean benchmark.

Model year2016 2015 2014 2013 2012 2011 2010 2009 2007

Quick specs

Fluid capacities, tune-up values and fuel economy at a glance.

Engine oil capacity7.4 qtOEM · verified

Engine oil type5W-30 / 10W-30 APIOEM · verified

Lug nut torque103 ft-lbsOEM · verified

Fitment & sizes

Replacement part sizes and factory part numbers — battery, bulbs, filters and belts.

From the factory this vehicle uses a BCI 48 · 600 CCA battery, OE oil filter 30750013. Each part links to every other vehicle that shares it, so a part you already stock may fit more of your fleet than you'd expect.

Battery groupBCI 48 · 600 CCAOEM · verified

Tire size245-45R17OEM · verified

Wheel / rim8.0-J inOEM · verified

OE service part numbers OEM · verified

Engine oil filter	30750013 alt 1275810
Engine air filter	30748212 alt 30745344
Fuel filter	32242190
Battery	30772236 alt 30772241
Front wiper blades	32341318
Thermostat	30720083 alt 30720315
Cabin air filter	31390880 alt 31449209

Full specifications

Engine, drivetrain, dimensions and economy.

Dimensions & weight NHTSA vPIC

Overall length	190.9 in
Overall width	73.2 in
Overall height	58.7 in
Wheelbase	111.8 in
Curb weight	3486 lb
Track (front / rear)	61.4 / 62.2 in

Performance & power Independent road tests

0–60 mph, quarter-mile, horsepower and torque from independent road tests.

Independent road tests for the S80 of this era, listed by trim and engine — this page spans more than one engine, so no single horsepower figure is shown.

5.7 sec0–60 mph (tested)quickest 5.70 sec — 2007 V8 Sedan

Year	Trim / engine	0–60	¼ mile	HP	Drivetrain
2007	V8 Sedan 4.4L V8	5.70 sec	14.40 sec	311 hp	AWD
2004	2.5T Sedan 2.5L Turbo I-5	7.70 sec	15.60 sec	208 hp	AWD
2002	T6 75th Anniversary Edition Sedan 2.9L Twin-Turbo I-6	6.30 sec	14.60 sec	268 hp	FWD
1999	T6 Sedan 2.8L Twin-Turbo I-6	6.80 sec	15.20 sec	268 hp	FWD
1999	T6 Sedan 2.8L Twin-Turbo I-6	7.10 sec	15.50 sec	268 hp	FWD

Service quick specs OEM factory data

Capacities, torques and tune-up values from the factory service manual.

This engine holds 7.4 qt of 5W-30 / 10W-30 API engine oil. Torque lug nuts to 103 ft-lbs. The firing order is 1-8-4-3-6-5-7-2.

Lubricants & capacities

Automatic Transmission Fluid	ATF
Automatic Transmission Fluid Capacity	7.0-8.0
Engine Oil	5W-30 · API · 10W-30
Engine Oil Capacity	7.4 qt
Engine Oil	5W-30 · API · 10W-30
Engine Oil Capacity	7.4 qt
Power Steering Fluid	SYNTHETIC

Engine torques

Engine Flywheel Bolts	26 ft-lbs
Intake Manifold to Engine Bolts	14 ft-lbs
Exhaust Manifold to Cylinder Head Bolts	18 ft-lbs
Main Bearings	59 ft-lbs

Chassis torques

Lug Nuts	103 ft-lbs
Transfer Case Fill Plug	27.0 ft-lbs
Transfer Case Drain Plug	27.0 ft-lbs
Front Wheel Hub	26 ft-lbs

Ignition

Cylinder Firing Order	1-5-3-6-2-4
Cylinder Firing Order	1-8-4-3-6-5-7-2
Curb Idle Speed (No Load)	675 rpm

Battery & A/C

Refrigerant	R134a
Refrigerant Capacity	3.2 L
Oil Type	Volvo part No. 1161 627-3
Oil Capacity	2.37 oz
Standard BCI Group Number	48
Standard BCI Cranking Performance	600 cca
Optional BCI Group Number	92
Optional BCI Cranking Performance	700 cca

Service checks

Fuel Pump Pressure Minimum	68 psi
Fuel Pump Pressure Maximum	70 psi
Injector Primary Resistance	12 ohms
Injector Primary Resistance	12 ohms

Brakes

Torque Caliper to Bracket	26 ft-lbs / 21 ft-lbs
Torque to Knuckle	81 ft-lbs / 148 ft-lbs
Minimum Pad Thickness	Front: 0.079; Rear: 0.079 in
Rotor Runout Limit	0.001 in / 0.0008 in
Rotor Nominal Thickness From	0.472 in / 0.433 in / 0.866 in / 1.102 in
Rotor Nominal Thickness To	0.472 in / 0.433 in / 0.866 in / 1.102 in
Rotor Minimum Machining	0.421 in / 0.381 in / 0.814 in / 1.043 in
Rotor Discard at or Under	0.393 in / 0.354 in / 0.787 in / 1.023 in

Multi-step torque procedures OEM · verified

Connecting Rod (Large End) Bearings — tightening sequence 1 stages

9 ft. lbs., Step 2: 15 ft. lbs., Step 3: 90

9 ft. lbs

Engine Flywheel Bolts — tightening sequence 1 stages

33 ft. lbs., Step 2: 60

33 ft. lbs

Main Bearings — tightening sequence 1 stages

33 ft. lbs., Step 2: 50

33 ft. lbs

Factory maintenance schedule OEM · verified

Normal service, condensed from the factory interval matrix.

Under the factory schedule, replace the engine oil and filter every 7,500 mi; spark plugs every 75,000 mi.

Every 7,500 mi	Brake Linings (inspect) · CV Joint Boot (inspect) · Driveshaft (inspect) · Engine Oil (drain & refill) · Engine Oil Filter (replace) · Exhaust System (Complete) (inspect)
Every 15,000 mi	Cabin Air Filter (replace) · Engine Coolant System (inspect fluid level) · Final Drive (inspect fluid level) · Parking Brake System (inspect) · Underbody (inspect)
Every 30,000 mi	Brake Line (inspect) · Fuel Line (inspect)
Every 37,500 mi	Brake Hydraulic System (drain, refill & bleed) · Engine Air Filter Element (replace)
At 60,000 mi	CV Joint Boot (inspect) · Driveshaft (inspect) · Exhaust System (Complete) (inspect) · Steering Linkage (inspect) · Suspension System (inspect)
Every 60,000 mi	Driveshaft (inspect)
Every 75,000 mi	Spark Plugs (replace)
At 120,000 mi	Drive Belt (replace)

Reliability & federal safety record

Owner-reported issues, recalls, investigations and service bulletins on record with NHTSA — an unfiltered look at what owners actually experience.

The 2007 Volvo S80 marks the debut of the second generation, and its federal record reflects a clean break from the troubled early years of the first generation (1999–2001), which saw up to 345 complaints and multiple investigations. While the 2007 model’s 24 complaints are a slight increase over the 12 recorded for 2006, they remain far below the peaks of the prior generation and are consistent with the low complaint levels that persist through 2016. Notably, the 2007 year carries zero investigations and zero crash or fire complaints, but it does have a high count of 245 technical service bulletins (TSBs), significantly above the 187 TSBs for 2006 and among the highest in the entire dataset, suggesting that Volvo proactively issued numerous service advisories to address early production refinements. The top complaint areas—structure, engine, electrical system/exterior lighting, and steering—are typical for a new model launch and do not point to any systemic safety defect. Overall, the 2007 S80 is a reasonable purchase from a reliability standpoint, but a buyer should verify that the extensive list of TSB-related updates has been performed to avoid lingering first-year quirks.

Open recalls

NHTSA campaigns

245

Service bulletins

Manufacturer communications

ODI investigations

Office of Defects Investigation

Owner complaints

0 involved a crash · 0 a fire

Owner complaints by model year NHTSA · this generation & adjacent

’99 ’00 ’01 ’02 ’03 ’04 ’05 ’06’07’08 ’09 ’10 ’11 ’12 ’13 ’14 ’15 ’16

Owner complaints filed with NHTSA, by component

All 24 complaints on record, top 8 components.

Structure4

Engine3

Electrical System,Exterior Lighting2

Steering2

Visibility,Structure1

Visibility/Wiper1

Suspension1

Electrical System1

Source: NHTSA Office of Defects Investigation complaint database.

Recalls NHTSA · verified

Showing 2 of 5 campaigns on record for this vehicle.

20V378000Seat Belts:FrontReported 30/06/2020

Volvo Cars of N.A., LLC (Volvo) is recalling certain 2008-2016 V70 and XC70, 2007-2016 S80, 2011-2018 S60 and V60, 2016-2018 S60 Cross Country, 2014-2020 S60L, 2009-2015 S80L, 2009-2016 XC60 and 2015-2018 V60 Cross… Remedy: Volvo will notify owners, and dealers will replace the seat belt anchor cable for both front seats. The recall began December 10, 2020. Owners may contact Volvo customer service…

11V378000Steering:Hydraulic Power Assist:Hose, Piping, And ConnectionsReported 26/07/2011

VOLVO IS RECALLING CERTAIN MODEL YEAR 2007 S80 PASSENGER CARS MANUFACTURED FROM MARCH 8, 2006, THROUGH MAY 16, 2007. THE POWER STEERING RESERVOIR RETURN HOSE MAY HAVE BEEN INCORRECTLY ROUTED, WHICH CAN RESULT IN… Remedy: VOLVO DEALERS WILL INSPECT THE ROUTING OF THE POWER STEERING RESERVOIR RETURN HOSE AND MAKE REPAIRS AS NECESSARY, FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN DURING…

Technical service bulletins NHTSA · verified

Showing 5 of 245 bulletins on record with NHTSA.

Bulletin	Date	Component	Summary
35526.1.8	2026-04-23	Engine	This is a Technical Journal: Text plus 2 PDFs and 1 .PNG Oil Consumption test. Perform…
37809.1.1	2026-04-07	Unknown Or Other	This is a TJ text only - The purpose of this TJ is to be a master reference list to…
19245	2025-12-06	Unknown Or Other	This is a Technical Journal. Vehicle type and platform identification.
8501	2025-04-10	Exterior Lighting	This is a Technical Journal: Remote connection, BOMGAR application. Before joining a…
S10303	2025-02-21	Unknown Or Other	Volvo Cars USA LLC and Volvo Car Canada LTD on behalf of the Volvo Car Corporation has…

Common OBD-II trouble codes

The most common OBD-II codes for this vehicle's emissions system. These are standardized SAE J2012 definitions, not vehicle-specific fault reports.

P0420

Catalyst system efficiency below threshold — Bank 1

P0300

Random / multiple cylinder misfire detected

P0171

System too lean — Bank 1

P0455

Evaporative emission system leak detected — large leak

P0128

Coolant thermostat below regulating temperature

P0442

Evaporative emission system leak detected — small leak

VIN tools

Decode factory build data for a specific vehicle by VIN.

VIN

Decode a VIN to confirm the transmission and build data for a specific S80. OEM

Build data

Plant, GVWR class, engine and body data for any 17-character VIN.

Recalls

Check open recall campaigns against a specific vehicle by VIN.

Vehicles with shared specs

Find every vehicle that shares this one's battery, bulbs, oil capacity, platform or parts.

Group 48 battery Vehicles taking 7.4 qt Engine oil filter 30750013 Engine air filter 30748212 Fuel filter 32242190 Battery 30772236

Reference guides

Cross-vehicle references for the kinds of data on this page.

Vehicle recalls & TSBs OBD-II trouble codes Torque specifications Maintenance schedules Fluid capacities & specs

Frequently asked

How much oil does the 2007 S80 take?

7.4 qt of BELOW 86 degrees F: 5W-30 API, -4 degrees F TO 104 degrees F: 10W-30 API, per the factory manual.

Does the 2007 S80 have open recalls?

NHTSA lists 5 recall campaign(s) for this model year. Check your specific vehicle by VIN.