Volvo›S80›2000›Overview/volvo/s80/2000/base/

2000 Volvo S80

Factory specifications, fluid capacities, torque values, EPA fuel economy and the federal safety record for the 2000 S80.

Body PASSENGER CAR

The 2000 Volvo S80 is a passenger‑car built on Volvo’s contemporary platform and powered by a drivetrain that requires 7.3 qt of 5W‑30 or 10W‑30 API‑rated oil, reflecting the model’s emphasis on durability and serviceability. Across the 1999‑2016 production span this year registered the highest owner‑complaint count at 345, with vehicle‑speed control identified as the most frequent issue and five recalls issued to address related concerns. Despite that concentration of complaints, the S80’s overall reliability trajectory shows a marked decline in problems in later years, suggesting that the 2000 model sits at the early, more trouble‑prone end of an otherwise improving reliability curve.

Model year2016 2015 2014 2013 2012 2011 2010 2009 2000

Quick specs

Fluid capacities, tune-up values and fuel economy at a glance.

Engine oil capacity7.3 qtOEM · verified

Engine oil type5W-30 / 10W-30 APIOEM · verified

Lug nut torque103 ft-lbsOEM · verified

Fitment & sizes

Replacement part sizes and factory part numbers — battery, bulbs, filters and belts.

From the factory this vehicle uses a BCI 48 · 600 CCA battery, OE oil filter 1275810. Note the factory battery is now discontinued — plan on a superseded or quality aftermarket equivalent, which the part pages below list where known. Each part links to every other vehicle that shares it, so a part you already stock may fit more of your fleet than you'd expect.

Battery groupBCI 48 · 600 CCAOEM · verified

Tire size215-55R16OEM · verified

Wheel / rim7-J inOEM · verified

OE service part numbers OEM · verified

Engine oil filter	1275810
Engine air filter	9186361
Fuel filter	30817997
Battery	9459948 discontinued · alt 9459949
Front wiper blades	30699740 alt 30699738
Serpentine belt	30731808
Thermostat	272335 alt 270854
Cabin air filter	30630752 alt 30630754

Full specifications

Engine, drivetrain, dimensions and economy.

Dimensions & weight NHTSA vPIC

Overall length	189.8 in
Overall width	72 in
Overall height	57.1 in
Wheelbase	109.8 in
Curb weight	3598 lb
Track (front / rear)	62.2 / 61.4 in
Weight distribution (front / rear)	59/41

Performance & power Independent road tests

0–60 mph, quarter-mile, horsepower and torque from independent road tests.

Independent road tests for the S80 of this era, listed by trim and engine — this page spans more than one engine, so no single horsepower figure is shown.

5.7–7.7 sec0–60 mph (tested)quickest 5.70 sec — 2007 V8 Sedan

Year	Trim / engine	0–60	¼ mile	HP	Drivetrain
1999	T6 Sedan 2.8L Twin-Turbo I-6	6.80 sec	15.20 sec	268 hp	FWD
1999	T6 Sedan 2.8L Twin-Turbo I-6	7.10 sec	15.50 sec	268 hp	FWD
2002	T6 75th Anniversary Edition Sedan 2.9L Twin-Turbo I-6	6.30 sec	14.60 sec	268 hp	FWD
2004	2.5T Sedan 2.5L Turbo I-5	7.70 sec	15.60 sec	208 hp	AWD
2007	V8 Sedan 4.4L V8	5.70 sec	14.40 sec	311 hp	AWD

Service quick specs OEM factory data

Capacities, torques and tune-up values from the factory service manual.

This engine holds 7.3 qt of 5W-30 / 10W-30 API engine oil, DOT 4 brake fluid. Torque lug nuts to 103 ft-lbs, the oil drain plug to 22.0 ft-lbs. The firing order is 1-5-3-6-2-4.

Lubricants & capacities

Brake Fluid	DOT 4
Engine Oil	5W-30 · API · 10W-30
Engine Oil Capacity	7.3 qt
Engine Oil	5W-30 · API · 10W-30
Engine Oil Capacity	7.3 qt
Power Steering Fluid	SYNTHETIC

Engine torques

Intake Manifold to Engine Bolts	15 ft-lbs
Exhaust Manifold to Cylinder Head Bolts	19 ft-lbs
Intake Manifold to Engine Bolts	15 ft-lbs
Exhaust Manifold to Cylinder Head Bolts	19 ft-lbs
Engine Oil Pan Drain Plug	29.0 ft-lbs
Engine Oil Pan Drain Plug	22.0 ft-lbs
Oil Pump to Cylinder BLock Bolts/Studs	7 ft-lbs

Chassis torques

Lug Nuts	103 ft-lbs
Front Wheel Hub	37 ft-lbs

Ignition

Cylinder Firing Order	1-5-3-6-2-4
Curb Idle Speed (No Load)	650 rpm
Curb Idle Speed Variance (No Load)	50 rpm
Ignition Coil Primary Resistance	0.5-1.5 ohms
Ignition Coil Secondary Resistance	8000-9000 ohms
Spark Plug Gap	0.028-0.032 in
Spark Plug Torque	18.0 ft-lbs
Spark Plug Gap	0.027 in

Battery & A/C

Refrigerant	R134a
Refrigerant Capacity	2.20 lbs
Oil Type	Volvo part No. 1161 627-3
Oil Capacity	6.08 oz
Standard BCI Group Number	48
Standard BCI Cranking Performance	600 cca
Optional BCI Group Number	49
Optional BCI Cranking Performance	800 cca

Service checks

RPM	43.0 rpm
Injector Primary Resistance	12 ohms
Engine Oil Pressure	14.5 psi @ 750 rpm, 50.76 psi @ 4000

Brakes

Wheel Application	15 inch WHEELS / 16 inch WHEELS
Torque Caliper to Bracket	27 ft-lbs
Torque to Knuckle	75 ft-lbs
Minimum Pad Thickness	Front: 0.079; Rear: 0.079 in
Wheel Application	15 inch WHEELS / 16 inch WHEELS
Rotor Max Parallel Variation	0.0003 in
Rotor Runout Limit	0.0008 in
Rotor Nominal Thickness From	1.02 in / 1.1 in / 0.47 in

Multi-step torque procedures OEM · verified

Connecting Rod (Large End) Bearings — tightening sequence 1 stages

15 ft. lbs, Step 2: 90

15 ft. lbs

Engine Flywheel Bolts — tightening sequence 1 stages

33 ft. lbs., Step 2: 65

33 ft. lbs

Factory maintenance schedule OEM · verified

Normal service, condensed from the factory interval matrix.

Under the factory schedule, replace the engine oil and filter every 7,500 mi.

Every 7,500 mi	Battery (inspect electrolyte level) · Brake System (inspect) · Engine Oil (drain & refill) · Engine Oil Filter (replace) · Fuel Line (inspect) · Tire & Wheel Assembly (rotate)
At 15,000 mi	Body Latches, Locks & Hinges (inspect) · Cabin Air Filter (replace) · Power Steering System (inspect) · Radio Antenna (clean) · Weatherstrip Seal (inspect)
Every 15,000 mi	Engine Coolant System (leak inspection) · Headlamp (inspect alignment) · Windshield Wiper Blade (inspect)
Every 30,000 mi	Accessory Drive Belt (inspect) · Body Latches, Locks & Hinges (inspect) · Brake Hydraulic System (drain, refill & bleed) · Cabin Air Filter (replace) · Engine Air Filter Element (replace) · Engine Breather Filter (inspect)
At 60,000 mi	Engine Breather Filter (inspect) · PCV Hose (inspect) · PCV Valve (inspect)
Every 60,000 mi	Drive Belt (replace)
At 105,000 mi	Fuel Filter (replace) · Timing Belt (replace)
At 180,000 mi	PCV Valve (inspect)

Reliability & federal safety record

Owner-reported issues, recalls, investigations and service bulletins on record with NHTSA — an unfiltered look at what owners actually experience.

The 2000 Volvo S80 stands out as the peak complaint year in the generation, with 345 complaints—a sharp rise from 214 in 1999 and followed by a steep decline to 180 in 2001. Recalls held steady at 5 for both 1999 and 2000, while investigations (2 each year) were only active in these first two model years, disappearing entirely afterward. The top complaint category for 2000 is Vehicle Speed Control at 75 reports, with Engine & Engine Cooling (43) and Electrical System (37) also prominent, alongside 18 crash-related and 8 fire-related complaints. This spike in reported problems, particularly in critical areas like speed control, places the 2000 model year at the high-water mark of early-generation issues before a significant drop in complaints in subsequent years. The data suggests the 2000 S80 carries a notably higher risk of reliability and safety concerns compared to later model years, making it a less advisable choice.

Open recalls

NHTSA campaigns

228

Service bulletins

Manufacturer communications

ODI investigations

Office of Defects Investigation

345

Owner complaints

18 involved a crash · 8 a fire

Owner complaints by model year NHTSA · this generation & adjacent

’99’00’01 ’02 ’03 ’04 ’05 ’06 ’07 ’08 ’09 ’10 ’11 ’12 ’13 ’14 ’15 ’16

Owner complaints filed with NHTSA, by component

All 345 complaints on record, top 8 components.

Vehicle Speed Control75

Engine & Engine Cooling43

Electrical System37

Fuel System, Gasoline24

Suspension17

Power Train14

Steering13

Service Brakes, Hydraulic10

Source: NHTSA Office of Defects Investigation complaint database.

Recalls NHTSA · verified

Showing 2 of 5 campaigns on record for this vehicle.

10V566000Equipment:Electrical:Navigational System(Global Positioning System)Reported 08/11/2010

VOLVO IS RECALLING CERTAIN VEHICLES EQUIPPED WITH GARMIN 760 PORTABLE GLOBAL POSITIONING SYSTEM (GPS) UNITS BECAUSE THE BATTERIES ON THOSE UNITS MAY OVERHEAT. Remedy: VOLVO ADVISES OWNERS TO PLEASE STOP USING THE GARMIN PORTABLE GPS DEVICE IMMEDIATELY, AND VISIT THE GARMIN WEBSITE TO DETERMINE IF THEIR UNIT IS AFFECTED. THE UNIT'S BATTERY WILL…

06V441000Vehicle Speed ControlReported 15/11/2006

ON CERTAIN PASSENGER VEHICLES, A COMBINATION OF THROTTLE POSITIONING SENSOR IRREGULARITIES, A DIRTY THROTTLE HOUSING, AND/OR INEFFICIENT SOFTWARE CALIBRATION MAY CAUSE A WARNING LAMP TO LIGHT AND THE SUBSEQUENT ONSET OF… Remedy: DEALERS WILL INSTALL THE CURRENT SOFTWARE UPGRADE ONTO THE INVOLVED VEHICLES. THE RECALL BEGAN ON DECEMBER 29, 2006. OWNERS MAY CONTACT VOLVO AT 1-800-458-1552.

Technical service bulletins NHTSA · verified

Showing 5 of 228 bulletins on record with NHTSA.

Bulletin	Date	Component	Summary
35526.1.8	2026-04-23	Engine	This is a Technical Journal: Text plus 2 PDFs and 1 .PNG Oil Consumption test. Perform…
37809.1.1	2026-04-07	Unknown Or Other	This is a TJ text only - The purpose of this TJ is to be a master reference list to…
19245	2025-12-06	Unknown Or Other	This is a Technical Journal. Vehicle type and platform identification.
8501	2025-04-10	Exterior Lighting	This is a Technical Journal: Remote connection, BOMGAR application. Before joining a…
S10303	2025-02-21	Unknown Or Other	Volvo Cars USA LLC and Volvo Car Canada LTD on behalf of the Volvo Car Corporation has…

Common OBD-II trouble codes

The most common OBD-II codes for this vehicle's emissions system. These are standardized SAE J2012 definitions, not vehicle-specific fault reports.

P0420

Catalyst system efficiency below threshold — Bank 1

P0300

Random / multiple cylinder misfire detected

P0171

System too lean — Bank 1

P0455

Evaporative emission system leak detected — large leak

P0128

Coolant thermostat below regulating temperature

P0442

Evaporative emission system leak detected — small leak

VIN tools

Decode factory build data for a specific vehicle by VIN.

VIN

Decode a VIN to confirm the transmission and build data for a specific S80. OEM

Build data

Plant, GVWR class, engine and body data for any 17-character VIN.

Recalls

Check open recall campaigns against a specific vehicle by VIN.

Vehicles with shared specs

Find every vehicle that shares this one's battery, bulbs, oil capacity, platform or parts.

Group 48 battery Vehicles taking 7.3 qt Engine oil filter 1275810 Engine air filter 9186361 Fuel filter 30817997 Battery 9459948

Reference guides

Cross-vehicle references for the kinds of data on this page.

Vehicle recalls & TSBs OBD-II trouble codes Torque specifications Maintenance schedules Fluid capacities & specs

Frequently asked

How much oil does the 2000 S80 take?

7.3 qt of BELOW 86 degrees F: 5W-30 API, -4 degrees F TO 104 degrees F: 10W-30 API, per the factory manual.

Does the 2000 S80 have open recalls?

NHTSA lists 5 recall campaign(s) for this model year. Check your specific vehicle by VIN.