Volkswagen›CC›2010›Overview/volkswagen/cc/2010/base/

2010 Volkswagen CC

Factory specifications, fluid capacities, torque values, EPA fuel economy and the federal safety record for the 2010 CC.

Body PASSENGER CAR

The 2010 Volkswagen CC is a passenger car that requires 4.5 quarts of engine oil with approved viscosities of 0W-40, 5W-30, or 5W-40. Among the model's 2008-2017 production run, the 2010 model year represents a troubling peak in owner dissatisfaction, accumulating 242 total complaints—the highest of any year in that span—with air bags emerging as the leading complaint area and four recalls issued for the model year. This stands in stark contrast to the 2008 launch year, which recorded just one owner complaint across the same monitoring framework, suggesting that early production concerns had escalated significantly by this iteration.

Model year2019 2018 2017 2016 2015 2014 2013 2012 2010

Quick specs

Fluid capacities, tune-up values and fuel economy at a glance.

Engine oil capacity4.5 qtOEM · verified

Engine oil type0W-40 / 5W-30 / 5W-40OEM · verified

Lug nut torque89 ft-lbsOEM · verified

Fitment & sizes

Replacement part sizes and factory part numbers — battery, bulbs, filters and belts.

From the factory this vehicle uses a BCI 48 · 640 CCA battery, OE oil filter 06J115403Q. Each part links to every other vehicle that shares it, so a part you already stock may fit more of your fleet than you'd expect.

Battery groupBCI 48 · 640 CCAOEM · verified

Tire sizeP235-45R17OEM · verified

Wheel / rim7.5 inOEM · verified

OE service part numbers OEM · verified

Engine oil filter	06J115403Q alt 066115111A
Engine air filter	1K0129620G alt 1K0129620
Fuel filter	3AA919715 alt 06H103484A
Spark plug	101905622 alt 06H905601A
Battery	000915089F alt 000915089E
Front wiper blades	3C1998002 alt 3C8955425B
Serpentine belt	022145933AP alt 06J260849D
Thermostat	06J121113C alt 03H121113D
Cabin air filter	1K1819669 alt 1K0819644B

Full specifications

Engine, drivetrain, dimensions and economy.

Dimensions & weight NHTSA vPIC

Overall length	189 in
Overall width	73.2 in
Overall height	55.9 in
Wheelbase	106.7 in
Curb weight	3373 lb
Track (front / rear)	60.6 / 61 in
Weight distribution (front / rear)	59/41

Performance & power Independent road tests

0–60 mph, quarter-mile, horsepower and torque from independent road tests.

Independent road tests for the CC of this era, listed by trim and engine — this page spans more than one engine, so no single horsepower figure is shown.

6.4–6.8 sec0–60 mph (tested)quickest 6.40 sec — 2010 R-Line 2.0T

Year	Trim / engine	0–60	¼ mile	HP	Drivetrain
2010	R-Line 2.0T 2.0L Turbo I-4	6.40 sec	15.00 sec	200 hp	FWD
2010	Sport 2.0T 2.0L Turbo I-4	6.80 sec	15.30 sec	200 hp	FWD
2009	VR6 4Motion V6 3.6L V6	6.10 sec	14.60 sec	280 hp	AWD
2009	VR6 4Motion V6 3.6L V6	6.20 sec	14.80 sec	280 hp	AWD
2009	VR6 4Motion V6 3.6L V6	6.60 sec	14.90 sec	280 hp	AWD
2009	Luxury 2.0T 2.0L Turbo I-4	7.00 sec	15.30 sec	200 hp	FWD
2013	Sport 2.0T 2.0L Turbo I-4	6.40 sec	14.90 sec	200 hp	FWD
2013	Lux 2.0T 2.0L Turbo I-4	6.50 sec	15.00 sec	200 hp	FWD

Service quick specs OEM factory data

Capacities, torques and tune-up values from the factory service manual.

This engine holds 4.5 qt of 0W-40 / 5W-30 / 5W-40 engine oil, DOT 4 brake fluid. Torque lug nuts to 89 ft-lbs. The firing order is 1-5-3-6-2-4. Note the cylinder-head bolts finish on a torque angle (torque-to-yield) — they stretch permanently and should be replaced, not reused, during any head service.

Lubricants & capacities

Automatic Transmission Fluid	ATF
Automatic Transmission Fluid Capacity	7.5
Brake Fluid	DOT 4
Engine Coolant	USE G012ABG-A1 COOLANT
Engine Oil	0W-40 · 5W-30 · 5W-40
Engine Oil Capacity	4.5 qt
Engine Oil	0W-40 · 5W-30 · 5W-40
Engine Oil Capacity	5.8 qt

Engine torques

Exhaust Manifold to Cylinder Head Bolts	18.4 ft-lbs
Oil Pump to Cylinder BLock Bolts/Studs	96 inch lbs. ft-lbs

Chassis torques

Lug Nuts	89 ft-lbs
Transfer Case Fill Plug	11.0 ft-lbs
Transfer Case Drain Plug	Bevel box: 44.0, Haldex Clutch: 22.0 ft-lbs

Ignition

Cylinder Firing Order	1-3-4-2
Cylinder Firing Order	1-5-3-6-2-4
Curb Idle Speed (No Load)	720 rpm
Curb Idle Speed Variance (No Load)	80 rpm
Curb Idle Speed (No Load)	700 rpm
Curb Idle Speed Variance (No Load)	60 rpm
Spark Plug Manufacturer	VW
Spark Plug Gap	0.039-0.043 in

Battery & A/C

Refrigerant	R134a
Refrigerant Capacity	1.12-1.29 lbs
Oil Group	PAG
Oil Type	46
Optional BCI Group Number	47
Optional BCI Cranking Performance	480 cca
Standard BCI Group Number	48
Standard BCI Cranking Performance	640 cca

Service checks

Fuel Pump Pressure Minimum	58.0 psi
Fuel Pump Pressure Maximum	101.0 psi
Residual Pressure	43.5 psi
Fuel Pump Pressure Minimum	58.0 psi
Fuel Pump Pressure Maximum	101.0 psi
Residual Pressure	43.5 psi
Injector Primary Resistance	12.0
Injector Primary Resistance	12.0

Brakes

Brake Application	WITH FN3 (16 inch) CALIPER PR NOS. 1LH/1ZG
Torque Caliper to Bracket	22 ft-lbs
Torque to Knuckle	148 ft-lbs
Brake Application	WITH FNR-G
Torque Caliper to Bracket	22 ft-lbs / 26 ft-lbs
Torque to Knuckle	140 ft-lbs
Brake Application	WITH CII 38 (16 inch) CALIPER PR NO 1KU
Torque Caliper to Bracket	26 ft-lbs

Multi-step torque procedures OEM · verified

Torque to Knuckle — tightening sequence 1 stages

Camshaft Bearing/Carrier Cap Bolts or Studs — tightening sequence 1 stages

6 ft. lbs., Step 2: 90

6 ft. lbs

Camshaft Bearing/Carrier Cap Bolts or Studs — tightening sequence 1 stages

4 ft. lbs., Step 2: 45

4 ft. lbs

Connecting Rod (Large End) Bearings — tightening sequence 1 stages

29 ft. lbs., Step 2: 90

29 ft. lbs

Crankshaft Pulley and/or Damper Bolts — tightening sequence 1 stages

74 ft. lbs., step 2: 180

74 ft. lbs

Cylinder Head — tightening sequence 5 stages

1	30 ft. lbs.	30 ft. lbs
2	90 degrees.	90 degrees
3	90 degrees.	90 degrees
4	Front bolts	6 ft. lbs
5	90 degrees.; Do not re-use old bolts.	90 degrees

Cylinder Head — tightening sequence 5 stages

1	30 ft. lbs.	30 ft. lbs
2	90 degrees.	90 degrees
3	90 degrees.	90 degrees
4	Front bolts	6 ft. lbs
5	90 degrees.; Do not re-use old bolts.	90 degrees

Cylinder Head — tightening sequence 4 stages

1	11 ft. lbs.	11 ft. lbs
2	22 ft. lbs.	22 ft. lbs
3	90 degrees	90 degrees
4	90 degrees; Apply liquid locking fluid-D 197 300 A2 sealant under head of bolts before installing the longer cylinder head bolts must be installed in the middle holes of the cylinder head.	90 degrees

Engine Flywheel Bolts — tightening sequence 1 stages

44 ft. lbs., Step 2: 90

44 ft. lbs

Engine Flywheel Bolts — tightening sequence 1 stages

44 ft. lbs., Step 2: 90

44 ft. lbs

Intake Manifold to Engine Bolts — tightening sequence 1 stages

2 ft. lbs., step 2: 7

2 ft. lbs

Exhaust Manifold to Cylinder Head Bolts — tightening sequence 1 stages

4 ft. lbs., step 2: 9 ft. lbs., step 3: 12 ft. lbs., step 4: 18

4 ft. lbs

Intake Manifold to Engine Bolts — tightening sequence 1 stages

2 ft. lbs., step 2: 7

2 ft. lbs

Exhaust Manifold to Cylinder Head Bolts — tightening sequence 1 stages

4 ft. lbs., step 2: 9 ft. lbs., step 3: 12 ft. lbs., step 4: 18

4 ft. lbs

Main Bearings — tightening sequence 1 stages

22 ft. lbs., Step 2: 180

22 ft. lbs

Factory maintenance schedule OEM · verified

Normal service, condensed from the factory interval matrix.

Under the factory schedule, replace the engine oil and filter every 10,000 mi; spark plugs every 60,000 mi.

Every 9,300 mi	Brake Linings (inspect)
Every 10,000 mi	Brake Rotor (inspect) · Engine Oil (drain & refill) · Engine Oil Filter (replace) · Headlamp Washer Nozzle (inspect) · Headlamp Washer System (inspect fluid level) · Tire & Wheel Assembly (rotate)
Every 20,000 mi	Battery (inspect) · Brake Hydraulic System (inspect fluid level) · Brake System (inspect) · Suspension Shock or Strut (inspect)
Every 40,000 mi	Accessory Drive Belt (inspect) · CV Joint Boot (inspect) · Cabin Air Filter (replace) · Door Hinge (lubricate) · Drive Axle Assembly (leak inspection) · Engine Assembly (leak inspection)
Every 60,000 mi	Air Intake Hose Debris Screen (clean) · Engine Air Filter Element (replace) · Engine Air Filter Housing (clean) · Spark Plugs (replace)

Reliability & federal safety record

Owner-reported issues, recalls, investigations and service bulletins on record with NHTSA — an unfiltered look at what owners actually experience.

The 2010 Volkswagen CC sits at the peak of the generation's complaint curve with 242 filings — the highest single-year total across the 2008–2017 span — marking a sharp escalation from 2009's 136 and a steep drop to 2011's 86. Recalls held steady at four for three consecutive years (2009–2011), while investigations rose to three in 2010 and remained there through 2014, and TSBs climbed steadily from 701 to 789. The complaint profile is dominated by Air Bags (63), Power Train (37), Engine (27), and Fuel/Propulsion System (19), with seven crash complaints and no fire reports recorded. The data doesn't specify root causes for these concentrations, but the 2010 spike stands out as an anomaly between lower-complaint adjacent years. TSB volume continued rising after 2010, suggesting ongoing service activity, but the complaint surge appears isolated to this model year. Given the highest complaint count in the generation and elevated safety-related filings, 2010 is a below-average year to buy; prioritize a thorough pre-purchase inspection focusing on air bag, powertrain, and fuel systems.

Open recalls

NHTSA campaigns

789

Service bulletins

Manufacturer communications

ODI investigations

Office of Defects Investigation

242

Owner complaints

7 involved a crash · 0 a fire

NHTSA crash-test rating federal NCAP · out of 5 stars

Rollover★★★★★

Owner complaints by model year NHTSA · this generation & adjacent

’08 ’09’10’11 ’12 ’13 ’14 ’15 ’16 ’17

Owner complaints filed with NHTSA, by component

All 242 complaints on record, top 8 components.

Air Bags63

Power Train37

Engine27

Fuel/Propulsion System19

Steering8

Unknown Or Other6

Fuel System, Gasoline6

Air Bags,Fuel/Propulsion System5

Source: NHTSA Office of Defects Investigation complaint database.

Recalls NHTSA · verified

Showing 2 of 4 campaigns on record for this vehicle.

18V148000Air Bags:Frontal:Driver Side:Inflator ModuleReported 06/03/2018

Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2009-2014 Volkswagen CC, 2010-2014 Golf, 2010-2014 Eos, 2007-2010 Passat Sedan and Wagon, and 2012-2014 Passat vehicles. Upon deployment of the… Remedy: Volkswagen will notify owners, and dealers will replace the driver's frontal air bag inflator with an alternative inflator, free of charge. The recall began March 16, 2018. Owners…

17V509000Fuel System, Gasoline:Delivery:Fuel PumpReported 16/08/2017

Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2009-2016 Volkswagen CC, 2006-2010 Passat and Passat Wagon vehicles. Interruption of electrical power to the fuel pump control module may cause the… Remedy: Volkswagen will notify owners, and dealers will replace the fuel pump control module, free of charge. The recall began June 26, 2018. Owners may contact Volkswagen customer…

Technical service bulletins NHTSA · verified

Showing 5 of 789 bulletins on record with NHTSA.

Bulletin	Date	Component	Summary
TT 10-18-02_2	2026-06-18	Engine	Lubricating engine components before reassembly.
TT 13-20-01_3	2026-06-18	Engine	Instruction, how to lubicate engine before initial start.
V6919012010479_17	2026-06-11	Air Bags	Inquiries
V1719012012855_81	2026-06-04	Engine	Volkswagen Engine Oil Standards
VOS-26-21	2026-03-27	Engine	This is a notice for software changes with the ODIS diagnostic program to correct the…

Common OBD-II trouble codes

The most common OBD-II codes for this vehicle's emissions system. These are standardized SAE J2012 definitions, not vehicle-specific fault reports.

P0420

Catalyst system efficiency below threshold — Bank 1

P0300

Random / multiple cylinder misfire detected

P0171

System too lean — Bank 1

P0455

Evaporative emission system leak detected — large leak

P0128

Coolant thermostat below regulating temperature

P0442

Evaporative emission system leak detected — small leak

VIN tools

Decode factory build data for a specific vehicle by VIN.

VIN

Decode a VIN to confirm the transmission and build data for a specific CC. OEM

Build data

Plant, GVWR class, engine and body data for any 17-character VIN.

Recalls

Check open recall campaigns against a specific vehicle by VIN.

Vehicles with shared specs

Find every vehicle that shares this one's battery, bulbs, oil capacity, platform or parts.

Group 48 battery Vehicles taking 4.5 qt Engine oil filter 06J115403Q Engine air filter 1K0129620G Fuel filter 3AA919715 Spark plug 101905622

Reference guides

Cross-vehicle references for the kinds of data on this page.

Vehicle recalls & TSBs OBD-II trouble codes Torque specifications Maintenance schedules Fluid capacities & specs

Frequently asked

How much oil does the 2010 CC take?

4.5 qt of 0W-40, 5W-30 OR 5W-40 MEETING VW SPECIFICATION 502.00, per the factory manual.

Does the 2010 CC have open recalls?

NHTSA lists 4 recall campaign(s) for this model year. Check your specific vehicle by VIN.

2010 Volkswagen CC

Quick specs

Fitment & sizes

OE service part numbers OEM · verified

Full specifications

Dimensions & weight NHTSA vPIC

Performance & power Independent road tests

Service quick specs OEM factory data

Lubricants & capacities

Engine torques

Chassis torques

Ignition

Battery & A/C

Service checks

Brakes

Multi-step torque procedures OEM · verified

Factory maintenance schedule OEM · verified

Reliability & federal safety record

Owner complaints filed with NHTSA, by component

Recalls NHTSA · verified

Technical service bulletins NHTSA · verified

Common OBD-II trouble codes

VIN tools

Vehicles with shared specs

Reference guides

Related vehicles

Other years

Frequently asked