ToyotaT1001997V6/toyota/t100/1997/v6/

1997 Toyota T100 — V6

Factory specifications, fluid capacities, torque values, EPA fuel economy and the federal safety record for the 1997 T100 V6.

Engine V6Transmission Automatic 4-spd

The 1997 Toyota T100 V6 is equipped with a 5.5‑quart V6 engine that calls for 10W‑30 or 5W‑30 API oil and is paired with a four‑speed automatic transmission, delivering EPA‑rated fuel economy of 15 mpg city, 18 mpg highway and 16 mpg combined. With a total of 75 owner complaints logged for the model year, the most frequent issue area is structure, and the vehicle is subject to one recall. Looking at the broader T100 complaint history from 1992‑1998, the 1997 model sits well below the peak of 118 complaints seen in 1996 and far above the low of just one complaint in 1992, indicating a mid‑range reliability standing for the generation.

Model year1998199719961995

Quick specs

Fluid capacities, tune-up values and fuel economy at a glance.

Engine oil capacity5.5 qtOEM · verified
Engine oil type10W-30 / 5W-30 APIOEM · verified
Lug nut torque76 ft-lbsOEM · verified
EPA fuel economy15/18/16 mpgEPA · verified

Fitment & sizes

Replacement part sizes and factory part numbers — battery, bulbs, filters and belts.

From the factory this vehicle uses a BCI 24F · 585 CCA battery, OE oil filter 90915YZZD1. Each part links to every other vehicle that shares it, so a part you already stock may fit more of your fleet than you'd expect.

Battery groupBCI 24F · 585 CCAOEM · verified
Tail / brake / turnFUSEOEM · verified

OE service part numbers OEM · verified

Engine oil filter90915YZZD1
Engine air filter178010W010
Fuel filter2330062020 alt 2330079446
Spark plug9091901192
Front wiper blades85212YZZ08TM
Serpentine belt9936481070 alt 993642086083
Thermostat9091603075 alt 9091603120

Full specifications

Engine, drivetrain, dimensions and economy.

Engine & drivetrain NHTSA vPIC

TransmissionAutomatic 4-spd

Dimensions & weight NHTSA vPIC

Overall length207.1 in
Overall width75.2 in
Overall height67.7 in
Wheelbase122 in
Curb weight3430 lb
Track (front / rear)61.8 / 63.8 in

Ratings & economy EPA / vPIC

EPA city / highway / combined15 / 18 / 16 mpg
DrivetrainRear-Wheel Drive
Recommended fuelRegular Gasoline

Performance & power Independent road tests

0–60 mph, quarter-mile, horsepower and torque from independent road tests.

No 1997 road test on record; the results below are same-engine tests from nearby model years, each shown under its own year.

8.9–11.5 sec0–60 mph (tested)quickest 8.90 sec — 1995 DX Xtracab (6'4.1" Bed)
YearTrim / engine0–60¼ mileHPDrivetrain
1995DX Xtracab (6'4.1" Bed) 3.4L V68.90 sec16.80 sec190 hp4x4
1995DX Xtracab (6'4.1" Bed) 3.4L V69.30 sec17.10 sec190 hp4x4
1993SR5 Regular Cab (8'1.8" Bed) 3.0L V611.50 sec18.60 sec150 hpRWD

Service quick specs OEM factory data

Capacities, torques and tune-up values from the factory service manual.

This engine holds 5.5 qt of 10W-30 / 5W-30 API engine oil, GL-5 · 80W-90 in the differential. Torque lug nuts to 76 ft-lbs. The firing order is 1-2-3-4-5-6.

Lubricants & capacities

Differential Gear OilGL-5 · 80W-90
Differential Gear Oil Capacity6 Pints
Engine Oil10W-30 · API · 5W-30
Engine Oil Capacity5.5 qt
Engine Oil10W-30 · API · 5W-30
Engine Oil Capacity5.6 qt
Engine Oil10W-30 · API · 5W-30
Engine Oil Capacity5 qt

Engine torques

Crankshaft Pulley and/or Damper Bolts192 ft-lbs
Crankshaft Pulley and/or Damper Bolts184 ft-lbs

Chassis torques

Leaf Spring to Axle (U-bolts)97.0 ft-lbs
Leaf Spring to Chassis Bracket1
Leaf Spring to Rear Shackle67.0 ft-lbs
Leaf Spring Rear Shackle to Chassis Bracket67.0 ft-lbs
Lug Nuts76 ft-lbs
Front Wheel Hub159 ft-lbs
Rear Wheel Hub159 ft-lbs

Ignition

Cylinder Firing Order1-2-3-4-5-6
Curb Idle Speed (No Load)700 rpm
Curb Idle Speed Variance (No Load)50 rpm
Curb Idle Speed (No Load)700 rpm
Curb Idle Speed Variance (No Load)50 rpm
Spark Plug ManufacturerDenso
Spark Plug Gap0.043 in
Spark Plug Torque13 ft-lbs

Battery & A/C

RefrigerantR134a
Refrigerant Capacity1.43 lbs
Oil GroupPAG
Oil TypeND 8 oil
Oil Capacity4.80 oz
Standard BCI Group Number24F
Standard BCI Cranking Performance585 cca

Service checks

Injector Primary Resistance13.4-14.2 na ohms
Engine Compression145-174 psi

Brakes

Torque Caliper to Bracket26 ft-lbs
Torque to Knuckle80 ft-lbs
Torque to Knuckle90 ft-lbs
Minimum Pad ThicknessFront: 0.039; Rear: 0.039 in
Minimum Shoe Thickness0.039 in
Rotor Runout Limit0.0028 in
Rotor Nominal Thickness From0.984 in
Rotor Nominal Thickness To0.984 in

Factory maintenance schedule OEM · verified

Normal service, condensed from the factory interval matrix.

Under the factory schedule, replace the engine oil and filter every 7,500 mi; spark plugs every 60,000 mi; coolant every 30,000 mi. The big-interval services (every 30,000 mi for coolant, and the transmission fluid) are the ones owners most often skip — on a lower-mileage example, assume the original fluids are still in it and check them first.

Every 7,500 miEngine Oil (drain & refill) · Engine Oil Filter (replace) · Tire & Wheel Assembly (rotate)
Every 15,000 miAccessory Drive Belt (inspect) · Axle Shaft Oil Seal (inspect) · Brake System (inspect) · CV Joint Boot (inspect) · Differential (inspect fluid level) · Drive Axle Assembly (inspect)
Every 30,000 miEngine Air Filter Element (replace) · Engine Coolant System (drain, flush & refill) · Fuel Line (inspect) · Fuel Tank (inspect)
At 60,000 miAccessory Drive Belt (inspect)
Every 60,000 miEngine Valves (inspect valve lash) · Fuel Evaporative Canister (inspect) · Spark Plugs (replace)

Reliability & federal safety record

Owner-reported issues, recalls, investigations and service bulletins on record with NHTSA — an unfiltered look at what owners actually experience.

In 1997 the T100 recorded 75 complaints, 1 recall, 1 investigation and 37 TSBs, placing it below the 1996 peak of 118 complaints and 2 recalls but above the 1998 drop to 26 complaints. The complaint distribution shows Structure, Power Train, Steering and Seat Belts as the leading categories, accounting for 16, 14, 12 and 9 complaints respectively, while crash‑related complaints numbered 3 and fire‑related complaints were zero. Compared with the surrounding years, 1997’s complaint volume follows a decline after the 1995‑1996 surge, indicating the upward trend has begun to recede. The single recall and investigation in 1997 mirror the pattern seen in 1994 and 1998, suggesting no new systemic defect was introduced that year. Because the complaint count and recall activity are moderate and fire complaints are absent, the 1997 model presents a relatively stable risk profile, making it a reasonable choice for a used purchase.

1
Open recalls
NHTSA campaigns
37
Service bulletins
Manufacturer communications
1
ODI investigations
Office of Defects Investigation
75
Owner complaints
3 involved a crash · 0 a fire
Owner complaints by model year NHTSA · this generation & adjacent

Owner complaints filed with NHTSA, by component

All 75 complaints on record, top 8 components.

Structure16
Power Train14
Steering12
Seat Belts9
Suspension5
Service Brakes, Hydraulic3
Unknown Or Other2
Engine & Engine Cooling2

Source: NHTSA Office of Defects Investigation complaint database.

Recalls NHTSA · verified

Showing 1 of 1 campaigns on record for this vehicle.

05V389000Steering:Linkages:Rod:Relay:ConnectingReported 06/09/2005

ON CERTAIN PICKUP TRUCKS AND SPORT UTILITY VEHICLES, IF THE STEERING WHEEL IS REPEATEDLY TURNED UNDER CERTAIN CONDITIONS WHERE HIGH STEERING EFFORT AND POWER ASSIST ARE REQUIRED, FOR INSTANCE, WHEN FULLY TURNING THE… Remedy: DEALERS WILL REPLACE THE STEERING RELAY ROD. THE RECALL BEGAN OCTOBER 5, 2005. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.

Technical service bulletins NHTSA · verified

Showing 5 of 37 bulletins on record with NHTSA.

BulletinDateComponentSummary
TSB0032202023-08-17Air BagsTSB: Replacement certification labels (the vinyl label installed on the driver door or…
Toyota PRO19-022022-01-12TiresPOL: This consolidated Tire Warranty Guide contains the complete warranty terms for all…
Toyota Safety Re2021-03-17Air BagsToyota Safety Recall and Service Campaign - Technician Certification Requirements
T-SB-0032-20 Rev2021-02-03EquipmentTSB: Replacement certification labels (the vinyl label installed on the driver door or…
T-SB-0304-17 Obs2020-04-07EquipmentTSB: OBSOLETE NOTICE April 07, 2020: This bulletin is now obsolete. Please see…

Common OBD-II trouble codes

The most common OBD-II codes for this vehicle's emissions system. These are standardized SAE J2012 definitions, not vehicle-specific fault reports.

P0420
Catalyst system efficiency below threshold — Bank 1
P0300
Random / multiple cylinder misfire detected
P0171
System too lean — Bank 1
P0455
Evaporative emission system leak detected — large leak
P0128
Coolant thermostat below regulating temperature
P0442
Evaporative emission system leak detected — small leak

VIN tools

Decode factory build data for a specific vehicle by VIN.

VIN
Decode a VIN to confirm the transmission and build data for a specific T100. OEM
Build data
Plant, GVWR class, engine and body data for any 17-character VIN.
Recalls
Check open recall campaigns against a specific vehicle by VIN.

Vehicles with shared specs

Find every vehicle that shares this one's battery, bulbs, oil capacity, platform or parts.

Reference guides

Cross-vehicle references for the kinds of data on this page.

Frequently asked

How much oil does the 1997 T100 V6 take?

5.5 qt of ABOVE 0 F: 10W-30 API, BELOW 100 F: 5W-30, per the factory manual.

Does the 1997 T100 have open recalls?

NHTSA lists 1 recall campaign(s) for this model year. Check your specific vehicle by VIN.

What gas mileage does the V6 get?

EPA figures are 15 city / 18 highway / 16 combined mpg.