Nissan›Pathfinder›2002›Overview/nissan/pathfinder/2002/base/

2002 Nissan Pathfinder

Factory specifications, fluid capacities, torque values, EPA fuel economy and the federal safety record for the 2002 Pathfinder.

Body SUV

The 2002 Nissan Pathfinder is a sport utility vehicle specified to take 5.3 quarts of 5W-30 API engine oil, the kind of routine maintenance benchmark that defined utility vehicles of its era. Across Nissan's model-year complaint history spanning 1990 to 2026, this generation logged 171 total owner complaints and 9 recalls, with engine and engine cooling emerging as the dominant problem area. Those figures place it well below the 2005 model year's peak of 1,050 complaints and well above the 7 recorded for 2026, locating the 2002 in a middle band of the historical record. For researchers, that midpoint is the most telling takeaway: a conventional SUV whose complaint profile already foreshadowed the sharper reliability pressures that would surface in subsequent model years.

Model year2025 2024 2023 2022 2020 2019 2018 2017 2002

Quick specs

Fluid capacities, tune-up values and fuel economy at a glance.

Engine oil capacity5.3 qtOEM · verified

Engine oil type5W-30 APIOEM · verified

Lug nut torque87-108 ft-lbsOEM · verified

Fitment & sizes

Replacement part sizes and factory part numbers — battery, bulbs, filters and belts.

From the factory this vehicle uses a BCI 25 · 360 CCA battery, OE oil filter 1520865F0E. Each part links to every other vehicle that shares it, so a part you already stock may fit more of your fleet than you'd expect.

Battery groupBCI 25 · 360 CCAOEM · verified

Tail / brake / turnHOTOEM · verified

Tire sizeP245-65R17OEM · verified

OE service part numbers OEM · verified

Engine oil filter	1520865F0E
Engine air filter	16546V0100
Fuel filter	164000W005
Spark plug	224015M014 alt 224015M016
Front wiper blades	288903W40A alt 2889040U01
Serpentine belt	11920AG900 alt 117204P102
Thermostat	212306N20A alt 1305031U00
Cabin air filter	27277VP03A

Full specifications

Engine, drivetrain, dimensions and economy.

Dimensions & weight NHTSA vPIC

Overall length	182.7 in
Overall width	69.7 in
Overall height	68.1 in
Wheelbase	106.3 in
Curb weight	4325 lb
Track (front / rear)	60.6 / 60.6 in
Weight distribution (front / rear)	55/45

Performance & power Independent road tests

0–60 mph, quarter-mile, horsepower and torque from independent road tests.

Independent road tests for the Pathfinder of this era, listed by trim and engine — this page spans more than one engine, so no single horsepower figure is shown.

9.2–11.5 sec0–60 mph (tested)quickest 9.20 sec — 2001 LE

Year	Trim / engine	0–60	¼ mile	HP	Drivetrain
2001	LE 3.5L V6	9.20 sec	17.00 sec	240 hp	4x4
1997	SE 3.3L V6	10.70 sec	17.90 sec	168 hp	4x4
1996	SE 3.3L V6	10.20 sec	17.90 sec	168 hp	4x4
1996	LE 3.3L V6	11.00 sec	18.20 sec	168 hp	4x4
1996	SE 3.3L V6	11.30 sec	18.40 sec	168 hp	4x4
1996	SE 3.3L V6	11.50 sec	18.40 sec	168 hp	4x4

Service quick specs OEM factory data

Capacities, torques and tune-up values from the factory service manual.

This engine holds 5.3 qt of 5W-30 API engine oil, 75W-90 · 80W-90 · GL-5 in the differential, DOT 3 brake fluid. Torque lug nuts to 87-108 ft-lbs, the oil drain plug to 22.0-29.0 ft-lbs. The firing order is 1-2-3-4-5-6. Note the cylinder-head bolts finish on a torque angle (torque-to-yield) — they stretch permanently and should be replaced, not reused, during any head service.

Lubricants & capacities

Brake Fluid	DOT 3
Differential Gear Oil	75W-90 · 80W-90 · GL-5
Differential Gear Oil Capacity	6 Pints
Engine Oil	5W-30 · API
Engine Oil Capacity	5.3 qt
Power Steering Fluid	ATF
Transfer Case Fluid	ATF
Transfer Case Fluid Capacity	4.6 Pints

Engine torques

Crankshaft Pulley and/or Damper Bolts	32-41 ft-lbs
Engine Flywheel Bolts	65 ft-lbs
Exhaust Manifold to Cylinder Head Bolts	21-24 ft-lbs
Engine Oil Pan Drain Plug	22.0-29.0 ft-lbs
Oil Pump to Cylinder BLock Bolts/Studs	5.0-6.0 ft-lbs

Chassis torques

Lug Nuts	87-108 ft-lbs
Transfer Case Fill Plug	18.0-25.0 ft-lbs
Transfer Case Drain Plug	18.0-25.0 ft-lbs

Ignition

Cylinder Firing Order	1-2-3-4-5-6
Curb Idle Speed (No Load)	750 rpm
Curb Idle Speed Variance (No Load)	50 rpm
Spark Plug Manufacturer	NGK
Spark Plug Gap	0.039-0.043 in
Spark Plug Torque	14-22 ft-lbs
Ignition Timing	15 degrees
Ignition Timing Acceptable Variance	2 degrees

Battery & A/C

Refrigerant	R134a
Refrigerant Capacity	.99 lbs
Oil Group	PAG
Oil Type	46
Oil Capacity	6.30 oz
Standard BCI Group Number	25
Standard BCI Cranking Performance	360 cca
Optional BCI Group Number	27

Service checks

Regulated Fuel System Pressure (Without Vacuum)	43.0 psi
Regulated Fuel System Pressure (With Vacuum)	34.0 psi
Injector Primary Resistance	13.5-17.5 ohms
Engine Compression	185-142 PSI. 14 Maximum variation PSI.
Engine Oil Pressure	43 psi
Engine Oil Pressure RPM	2000 rpm
Intake Valve Lash	0.012-0.016 in
Exhaust Valve Lash	0.012-0.017 in

Brakes

Torque Caliper to Bracket	16-23 ft-lbs
Torque to Knuckle	62 ft-lbs
Minimum Pad Thickness	Front: 0.079; Rear: 0.079 in
Rotor Runout Limit	0.0028 in
Rotor Nominal Thickness From	1.103 in
Rotor Nominal Thickness To	1.103 in
Rotor Minimum Machining	1.024 in
Rotor Discard at or Under	1.023 in

Multi-step torque procedures OEM · verified

Connecting Rod (Large End) Bearings — tightening sequence 1 stages

14-15 ft. lbs., Step 2: 90-95

14–15 ft. lbs

Cylinder Head — tightening sequence 5 stages

1	72 ft. lbs.	72 ft. lbs
2	Loosen all bolts.
3	26-32 ft. lbs.	26–32 ft. lbs
4	90-95 degrees.	90–95 degrees
5	90-95 degrees.	90–95 degrees

Intake Manifold to Engine Bolts — tightening sequence 1 stages

4-7 ft. lbs., step 2: 20-23 ft. lbs., step 3: 20-23

4–7 ft. lbs

Main Bearings — tightening sequence 1 stages

24-28 ft. lbs., Step 2: 95

24–28 ft. lbs

Factory maintenance schedule OEM · verified

Normal service, condensed from the factory interval matrix.

Under the factory schedule, replace the engine oil and filter every 7,500 mi; spark plugs at 105,000 mi; coolant every 30,000 mi. The big-interval services (every 30,000 mi for coolant, and the transmission fluid) are the ones owners most often skip — on a lower-mileage example, assume the original fluids are still in it and check them first.

Every 7,500 mi	Engine Oil (drain & refill) · Engine Oil Filter (replace) · Tire & Wheel Assembly (rotate)
Every 15,000 mi	Axle Shaft Oil Seal (inspect) · Brake System (inspect) · CV Joint Boot (inspect) · Differential (inspect fluid level) · Exhaust System (Complete) (inspect) · Transmission Assembly (inspect)
Every 30,000 mi	Accessory Drive Belt (inspect) · Drive Axle Assembly (drain & refill) · Engine Air Filter Element (replace) · Engine Coolant System (drain, flush & refill) · Fuel Evaporative Emission Control System Lines (inspect) · Steering Linkage (inspect)
At 60,000 mi	Engine Coolant System (drain, flush & refill)
Every 60,000 mi	Steering System (inspect) · Suspension Ball Joint (inspect)
At 105,000 mi	Spark Plugs (replace)

Reliability & federal safety record

Owner-reported issues, recalls, investigations and service bulletins on record with NHTSA — an unfiltered look at what owners actually experience.

The 2002 Pathfinder sits near the peak of the model‑line’s complaint and recall activity, recording 171 complaints, 9 recalls, and 2 investigations—higher than the early‑2000s average (e.g., 129 complaints and 6 recalls in 2000) but noticeably lower than the 2005 spike of 1,050 complaints. Across the generation, complaints rose steadily from the mid‑1990s, peaked dramatically in 2005, then fell sharply after 2009, while recalls followed a similar bell‑shaped pattern with a secondary rise in 2013‑2014. In 2002 the top issue areas were Engine & Engine Cooling (34 reports), Suspension (21) and Structure (12), and the vehicle logged 16 crash‑related and only 1 fire‑related complaint, indicating relatively modest safety‑critical problems for that year. Because 2002 falls on the descending side of the early‑generation surge but before the dramatic 2005 anomaly, it represents a comparatively moderate risk year; it can be considered a reasonable choice provided a thorough pre‑purchase inspection focuses on engine cooling and suspension components.

Open recalls

NHTSA campaigns

Service bulletins

Manufacturer communications

ODI investigations

Office of Defects Investigation

171

Owner complaints

16 involved a crash · 1 a fire

NHTSA crash-test rating federal NCAP · out of 5 stars

Rollover★★★★★

Owner complaints by model year NHTSA · this generation & adjacent

’90 ’91 ’92 ’93 ’94 ’95 ’96 ’97 ’98 ’99 ’00 ’01’02’03 ’04 ’05 ’06 ’07 ’08 ’09 ’10 ’11 ’12 ’13 ’14 ’15 ’16 ’17 ’18 ’19 ’20 ’22 ’23 ’24 ’25 ’26

Owner complaints filed with NHTSA, by component

All 171 complaints on record, top 8 components.

Engine & Engine Cooling34

Suspension21

Structure12

Vehicle Speed Control10

Air Bags9

Steering,Suspension7

Service Brakes, Hydraulic7

Fuel/Propulsion System6

Source: NHTSA Office of Defects Investigation complaint database.

Recalls NHTSA · verified

Showing 2 of 9 campaigns on record for this vehicle.

20V008000Air Bags:Frontal:Passenger Side:Inflator ModuleReported 09/01/2020

Nissan North America, Inc. (Nissan) is recalling certain 2001-2003 Maxima, 2002-2006 Sentra, 2002-2004 Pathfinder, 2007-2011 Versa Sedan and Versa Hatchback, 2001-2004 Infiniti I30 and I35, 2002-2003 Inifiniti QX4… Remedy: Nissan will notify owners, and dealers will replace the front passenger air bag inflators with alternate desiccated inflators, free of charge. The recall began February 12, 2020…

17V068000Air Bags:Frontal:Passenger Side:Inflator ModuleReported 02/02/2017

Nissan North America, Inc. (Nissan) is recalling certain 2002 Pathfinder and Infiniti QX4 vehicles. These vehicles are equipped with Takata air bag inflators assembled as part of the passenger frontal air bag modules… Remedy: Nissan will notify owners, and dealers will replace the front passenger air bag assembly, free of charge. The recall began on March, 31, 2017. Owners may contact Nissan customer…

Technical service bulletins NHTSA · verified

Showing 5 of 74 bulletins on record with NHTSA.

Bulletin	Date	Component	Summary
ITB09-063C	2026-04-13	Structure	CERTIFICATION LABEL AND VIN PLATE REPLACEMENT SERVICE INFORMATION Because of collision…
NTB09-131C	2026-04-13	Structure	CERTIFICATION LABEL AND VIN PLATE REPLACEMENT SERVICE INFORMATION Because of collision…
NTB09-131C	2026-04-13	Structure	CERTIFICATION LABEL AND VIN PLATE REPLACEMENT SERVICE INFORMATION Because of collision…
NTB13-107G	2024-05-20	Electrical System	VEHICLE KEY NOT DETECTED / AUTHENTICATED, ENGINE WILL NOT START This bulletin has been…
NTB17-019H	2024-04-29	Visibility/Wiper	WINDOW GLASS WARRANTY INFORMATION This bulletin has been amended. See AMENDMENT HISTORY…

Common OBD-II trouble codes

The most common OBD-II codes for this vehicle's emissions system. These are standardized SAE J2012 definitions, not vehicle-specific fault reports.

P0420

Catalyst system efficiency below threshold — Bank 1

P0300

Random / multiple cylinder misfire detected

P0171

System too lean — Bank 1

P0455

Evaporative emission system leak detected — large leak

P0128

Coolant thermostat below regulating temperature

P0442

Evaporative emission system leak detected — small leak

VIN tools

Decode factory build data for a specific vehicle by VIN.

VIN

Decode a VIN to confirm the transmission and build data for a specific Pathfinder. OEM

Build data

Plant, GVWR class, engine and body data for any 17-character VIN.

Recalls

Check open recall campaigns against a specific vehicle by VIN.

Vehicles with shared specs

Find every vehicle that shares this one's battery, bulbs, oil capacity, platform or parts.

Group 25 battery Vehicles taking 5.3 qt Engine oil filter 1520865F0E Engine air filter 16546V0100 Fuel filter 164000W005 Spark plug 224015M014

Reference guides

Cross-vehicle references for the kinds of data on this page.

Vehicle recalls & TSBs OBD-II trouble codes Torque specifications Maintenance schedules Fluid capacities & specs

Frequently asked

How much oil does the 2002 Pathfinder take?

5.3 qt of 5W-30 API, per the factory manual.

Does the 2002 Pathfinder have open recalls?

NHTSA lists 9 recall campaign(s) for this model year. Check your specific vehicle by VIN.