FordExplorer Sport Trac2010Overview/ford/explorer-sport-trac/2010/base/

2010 Ford Explorer Sport Trac

Factory specifications, fluid capacities, torque values, EPA fuel economy and the federal safety record for the 2010 Explorer Sport Trac.

Body SUV

The 2010 Ford Explorer Sport Trac is an SUV that takes 5.0 qt of 5W‑30 API engine oil, reflecting its powertrain specifications. With only 30 owner‑reported complaints for the model year and a single recall, its trouble spots are concentrated in the power train. Compared with the broader 2002‑2010 complaint history — where 2002 saw a peak of 3,620 issues and 2009 a trough of just six — the 2010 figure places it near the low end of the spectrum, indicating a marked improvement in reliability over the early years while still modestly above the 2009 benchmark.

Model year201020092008200720052004200320022001

Quick specs

Fluid capacities, tune-up values and fuel economy at a glance.

Engine oil capacity5.0 qtOEM · verified
Engine oil type5W-30 APIOEM · verified
Lug nut torque100 ft-lbsOEM · verified

Fitment & sizes

Replacement part sizes and factory part numbers — battery, bulbs, filters and belts.

From the factory this vehicle uses a BCI 65 · 650 CCA battery. Each part links to every other vehicle that shares it, so a part you already stock may fit more of your fleet than you'd expect.

Battery groupBCI 65 · 650 CCAOEM · verified
Tire sizeP245-65R17OEM · verified

Full specifications

Engine, drivetrain, dimensions and economy.

Dimensions & weight NHTSA vPIC

Overall length210.2 in
Overall width73.6 in
Overall height72 in
Wheelbase130.3 in
Curb weight4753 lb
Track (front / rear)60.6 / 61.8 in
Weight distribution (front / rear)56/44

Service quick specs OEM factory data

Capacities, torques and tune-up values from the factory service manual.

This engine holds 5.0 qt of 5W-30 API engine oil, SYNTHETIC · 75W-140 · GL-5 in the differential, DOT 3 brake fluid. Torque lug nuts to 100 ft-lbs, the oil drain plug to 19.0 ft-lbs. The firing order is 1-3-7-2-6-5-4-8. Note the cylinder-head bolts finish on a torque angle (torque-to-yield) — they stretch permanently and should be replaced, not reused, during any head service.

Lubricants & capacities

Automatic Transmission FluidATF
Automatic Transmission Fluid Capacity10.0-11.2
Brake FluidDOT 4
Brake FluidDOT 3
Differential Gear OilSYNTHETIC · 75W-140 · GL-5
Differential Gear Oil Capacity5 Pints, rear
Differential Gear OilSYNTHETIC · 75W-140 · GL-5
Differential Gear Oil Capacity3.6 Pints, Rear

Engine torques

Camshaft Bearing/Carrier Cap Bolts or Studs7.4 ft-lbs
Intake Manifold to Engine Bolts8 ft-lbs
Engine Oil Pan Drain Plug17.0-22.0 ft-lbs
Engine Oil Pan Drain Plug19.0 ft-lbs
Engine Oil Pan Drain Plug19.0 ft-lbs
Oil Pump to Cylinder BLock Bolts/Studs14 ft-lbs
Oil Pump to Cylinder BLock Bolts/Studs7 ft-lbs

Chassis torques

Lug Nuts100 ft-lbs
Transfer Case Fill Plug15.0 ft-lbs
Transfer Case Drain Plug9.0 if equipped with drain plug ft-lbs
Rear Wheel Hub203 ft-lbs
Front Wheel Hub184 ft-lbs
Front Wheel Hub184 ft-lbs
Rear Wheel Hub203 ft-lbs

Ignition

Cylinder Firing Order1-4-2-5-3-6
Cylinder Firing Order1-3-7-2-6-5-4-8
Spark Plug ManufacturerMotorcraft
Spark Plug Gap0.039-0.043 in
Spark Plug Torque9.0 ft-lbs
Ignition Timing10

Battery & A/C

RefrigerantR134a
Oil GroupPAG
Oil Type46
Standard BCI Group Number65
Standard BCI Cranking Performance650 cca
Standard BCI Group Number65
Standard BCI Cranking Performance650 cca

Service checks

Pressure Test22 psi
Radiator Cap Pressure Relief18-22 psi
Thermostat Opening Temperature194-201 °F
Pressure Test22 psi
Radiator Cap Pressure Relief18-22 psi
Thermostat Opening Temperature189-196 °F
Key ON Engine OFF (KOEO)30-40
RPM30-40 @ Idle rpm

Brakes

Torque Caliper to Bracket24 ft-lbs / 53 ft-lbs
Torque to Knuckle122 ft-lbs
Torque Caliper to Bracket53 ft-lbs / 24 ft-lbs
Torque to Knuckle122 ft-lbs
Minimum Pad ThicknessFront: 0.118; Rear: 0.118 in
Rotor Runout Limit0.002 in
Rotor Minimum Machining1.145 in / 0.456 in
Rotor Discard at or Under1.122 in / 0.433 in

Multi-step torque procedures OEM · verified

Connecting Rod (Large End) Bearings — tightening sequence 1 stages
115 ft. lbs., Step 2: 9015 ft. lbs
Connecting Rod (Large End) Bearings — tightening sequence 1 stages
117 ft. lbs. Step 2: 32 ft. lbs., Step 3: 10517 ft. lbs
Crankshaft Pulley and/or Damper Bolts — tightening sequence 1 stages
141 ft. lbs., step 2: 85 degrees SOHC41 ft. lbs
Crankshaft Pulley and/or Damper Bolts — tightening sequence 1 stages
189 ft. lbs., step 2: loosen one turn 37 ft. lbs. step 3: 9089 ft. lbs
Cylinder Head — tightening sequence 5 stages

Prep Do not reuse old bolts. Coat new bolts with the specified engine oil.

1M12 bolts9 ft. lbs
2M12 bolts18 ft. lbs
3M8 bolts24 ft. lbs
4M12 bolts90 degrees
5M12 bolts90 degrees
Cylinder Head — tightening sequence 5 stages

Prep Do not reuse old bolts. Coat new bolts with the specified engine oil.

1M12 bolts9 ft. lbs
2M12 bolts18 ft. lbs
3M8 bolts24 ft. lbs
4M12 bolts90 degrees
5M12 bolts90 degrees
Engine Flywheel Bolts — tightening sequence 1 stages
110 ft. lbs., Step 2: 5210 ft. lbs
Engine Flywheel Bolts — tightening sequence 1 stages
115 ft. lbs., Step 2: 5915 ft. lbs
Exhaust Manifold to Cylinder Head Bolts — tightening sequence 1 stages
1install 6 new exhaust manifold stud9 ft. lbs
Intake Manifold to Engine Bolts — tightening sequence 1 stages
1Tighten in sequence shown1.5 ft. lbs
Main Bearings — tightening sequence 1 stages
125 ft. lbs., Step 2: 67-7525 ft. lbs

Factory maintenance schedule OEM · verified

Normal service, condensed from the factory interval matrix.

Under the factory schedule, replace the engine oil and filter every 7,500 mi; spark plugs every 90,000 mi; coolant every 45,000 mi. The big-interval services (every 45,000 mi for coolant, and the transmission fluid) are the ones owners most often skip — on a lower-mileage example, assume the original fluids are still in it and check them first.

Every 7,500 miEngine Oil (drain & refill) · Engine Oil Filter (replace) · Tire & Wheel Assembly (rotate)
Every 15,000 miBrake System (inspect) · CV Joint Boot (inspect) · Cabin Air Filter (replace) · Driveshaft (inspect) · Driveshaft U-Joint (inspect) · Engine Coolant System (inspect fluid level)
Every 30,000 miAccessory Drive Belt (inspect) · Engine Air Filter Element (replace) · Fuel Filter (replace) · Temperature Controlled Seat Air Filter (replace)
Every 45,000 miEngine Coolant System (drain, flush & refill)
Every 60,000 miWheel Bearing (repack)
At 90,000 miAccessory Drive Belt (inspect)
Every 90,000 miSpark Plugs (replace)
At 105,000 miEngine Coolant System (drain, flush & refill)
At 150,000 miDrive Axle Assembly (drain & refill) · Drive Belt (replace) · Transmission Fluid & Filter (replace)

Reliability & federal safety record

Owner-reported issues, recalls, investigations and service bulletins on record with NHTSA — an unfiltered look at what owners actually experience.

The 2010 Ford Explorer Sport Trac recorded 30 federal complaints, 1 recall, 1 investigation and 17 TSBs. That complaint count is up from 6 in 2009 but still far below the peak of 3,620 complaints logged in 2002. The single recall in 2010 matches the 2009 recall count, while investigations rose from zero to one. The most frequently cited problem categories were Power Train (6 complaints), Seats (3), Engine (2) and Structure (2), with an additional 2 crash‑related and 2 fire‑related complaints. Given the modest recent complaint volume and the absence of major recall activity, the 2010 model year appears to be a reasonable purchase.

1
Open recalls
NHTSA campaigns
17
Service bulletins
Manufacturer communications
1
ODI investigations
Office of Defects Investigation
30
Owner complaints
2 involved a crash · 2 a fire
NHTSA crash-test rating federal NCAP · out of 5 stars
Rollover★★★★
Owner complaints by model year NHTSA · this generation & adjacent

Owner complaints filed with NHTSA, by component

All 30 complaints on record, top 8 components.

Power Train6
Seats3
Engine2
Structure2
Air Bags2
Wheels2
Service Brakes, Hydraulic2
Engine & Engine Cooling2

Source: NHTSA Office of Defects Investigation complaint database.

Recalls NHTSA · verified

Showing 1 of 1 campaigns on record for this vehicle.

10V161000Seats:Front Assembly:ReclinerReported 20/04/2010

FORD IS RECALLING CERTAIN MODEL YEAR 2010 FUSION, EXPLORER, EXPLORER SPORT TRAC, AND MERCURY MILAN AND MOUNTAINEER VEHICLES MANUFACTURED BETWEEN DECEMBER 15, 2009 THROUGH FEBRUARY 3, 2010 EQUIPPED WITH FRONT SEAT MANUAL… Remedy: DEALERS WILL REPLACE THE MANUAL RECLINERS FOR BOTH POWER AND MANUAL SEATS FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OR BEFORE APRIL 30, 2010. OWNERS MAY CONTACT…

Technical service bulletins NHTSA · verified

Showing 5 of 17 bulletins on record with NHTSA.

BulletinDateComponentSummary
SSM 546012026-02-23Electrical SystemFord and Lincoln vehicles equipped with wired keyless entry keypad systems and accessory…
SSM 524762024-04-24EquipmentAll accessory stick-on keyless entry keypads come with a wallet card containing the…
SSM 481302019-08-09VisibilitySome 2010-2020 vehicles may exhibit distorted glass with a subtle orange peel pattern or…
SSM 479762019-05-10Power TrainOn vehicles equipped with an automatic transmission it is imperative that the converter…
DOR-S3J9G-112018-10-02SteeringThis SKU is a front upper ball joint. The Customer communication requested return of…

Common OBD-II trouble codes

The most common OBD-II codes for this vehicle's emissions system. These are standardized SAE J2012 definitions, not vehicle-specific fault reports.

P0420
Catalyst system efficiency below threshold — Bank 1
P0300
Random / multiple cylinder misfire detected
P0171
System too lean — Bank 1
P0455
Evaporative emission system leak detected — large leak
P0128
Coolant thermostat below regulating temperature
P0442
Evaporative emission system leak detected — small leak

VIN tools

Decode factory build data for a specific vehicle by VIN.

VIN
Decode a VIN to confirm the transmission and build data for a specific Explorer Sport Trac. OEM
Build data
Plant, GVWR class, engine and body data for any 17-character VIN.
Recalls
Check open recall campaigns against a specific vehicle by VIN.

Vehicles with shared specs

Find every vehicle that shares this one's battery, bulbs, oil capacity, platform or parts.

Reference guides

Cross-vehicle references for the kinds of data on this page.

Frequently asked

How much oil does the 2010 Explorer Sport Trac take?

5.0 qt of 5W-30 API MEETING FORD SPECIFICATION WSS-M2C946-A, per the factory manual.

Does the 2010 Explorer Sport Trac have open recalls?

NHTSA lists 1 recall campaign(s) for this model year. Check your specific vehicle by VIN.