FordE-2502012Overview/ford/e-250/2012/base/
250 platform

2012 Ford E-250

Factory specifications, fluid capacities, torque values, EPA fuel economy and the federal safety record for the 2012 E.

Body VAN

The 2012 Ford E-250 is a VAN built on the 250 platform and equipped with an engine that holds six quarts of 5W‑20 API oil. It records twelve owner complaints and eight recalls, with power‑train problems accounting for the majority of the feedback. In a complaint history that ranges from a low of one complaint in 1990 to a high of 28 in 1998, the 2012 model falls into a mid‑range position, suggesting reliability that is moderate relative to its three‑decade record.

Model year20172016201520142012

Quick specs

Fluid capacities, tune-up values and fuel economy at a glance.

Engine oil capacity6.0 qtOEM · verified
Engine oil type5W-20 APIOEM · verified
Lug nut torque140-150 ft-lbsOEM · verified

Fitment & sizes

Replacement part sizes and factory part numbers — battery, bulbs, filters and belts.

From the factory this vehicle uses a BCI 65 · 650 CCA battery. Each part links to every other vehicle that shares it, so a part you already stock may fit more of your fleet than you'd expect.

Battery groupBCI 65 · 650 CCAOEM · verified

Full specifications

Engine, drivetrain, dimensions and economy.

Dimensions & weight NHTSA vPIC

Overall length216.5 in
Overall width79.5 in
Overall height82.3 in
Wheelbase138.2 in
Curb weight4645 lb
Track (front / rear)70.1 / 66.9 in
Weight distribution (front / rear)58/42

Service quick specs OEM factory data

Capacities, torques and tune-up values from the factory service manual.

This engine holds 6.0 qt of 5W-20 API engine oil, DOT 3 brake fluid. Torque lug nuts to 140-150 ft-lbs, the oil drain plug to 10.0 ft-lbs. The firing order is 1-3-7-2-6-5-4-8. Note the cylinder-head bolts finish on a torque angle (torque-to-yield) — they stretch permanently and should be replaced, not reused, during any head service.

Lubricants & capacities

Automatic Transmission FluidFord Mercon LV
Automatic Transmission Fluid Capacity13.9
Brake FluidDOT 3
Engine Oil5W-20 · API
Engine Oil Capacity6.0 qt
Engine Oil5W-20 · API
Engine Oil Capacity6.0 qt
Power Steering FluidATF

Engine torques

Camshaft Bearing/Carrier Cap Bolts or Studs7.4 ft-lbs
Intake Manifold to Engine Bolts7.4 ft-lbs
Exhaust Manifold to Cylinder Head Bolts18 ft-lbs
Engine Oil Pan Drain Plug19.0 ft-lbs
Engine Oil Pan Drain Plug10.0 ft-lbs
Oil Pump to Cylinder BLock Bolts/Studs7 ft-lbs

Chassis torques

Leaf Spring to Chassis Bracket258.0 ft-lbs
Leaf Spring to Rear Shackle98.0 ft-lbs
Leaf Spring Rear Shackle to Chassis Bracket98.0 ft-lbs
Lug Nuts140-150 ft-lbs

Ignition

Cylinder Firing Order1-3-7-2-6-5-4-8
Spark Plug ManufacturerMotorcraft
Spark Plug Gap0.043-0.047 in
Spark Plug Torque10.0 ft-lbs
Ignition Timing10

Battery & A/C

RefrigerantR134a
Oil GroupPAG
Oil Type46
Standard BCI Group Number65
Standard BCI Cranking Performance650 cca
Standard BCI Group Number65
Standard BCI Cranking Performance650 cca

Service checks

Pressure Test13-18 psi
Radiator Cap Pressure Relief13-18 psi
Thermostat Opening Temperature188-195 °F
Key ON Engine OFF (KOEO)55-60
RPM55-60 @ Idle rpm
Injector Primary Resistance11-18 na ohms
Injector Primary Resistance11-18 na ohms
Engine Oil Pressure20-45 psi

Brakes

Torque Caliper to Bracket27 ft-lbs / 45 ft-lbs
Torque to Knuckle195 ft-lbs / 166 ft-lbs
Minimum Pad ThicknessFront: 0.118; Rear: 0.039 in
Rotor Runout Limit0.002 in
Rotor Discard at or Under1.511 in / 1.354 in

Multi-step torque procedures OEM · verified

Connecting Rod (Large End) Bearings — tightening sequence 1 stages
117 ft. lbs. Step 2: 32 ft. lbs., Step 3: 10517 ft. lbs
Crankshaft Pulley and/or Damper Bolts — tightening sequence 1 stages
189 ft. lbs., step 2: loosen one turn 37 ft. lbs. step 3: 9089 ft. lbs
Crankshaft Pulley and/or Damper Bolts — tightening sequence 1 stages
166 ft. lbs., step 2: loosen one turn 37 ft. lbs., step 3: 9066 ft. lbs
Cylinder Head — tightening sequence 3 stages

Prep Do not reuse old bolts. Coat new bolts with the specified engine oil.

130.0 ft. lbs.30 ft. lbs
290 degrees90 degrees
390 degrees90 degrees
Engine Flywheel Bolts — tightening sequence 1 stages
115 ft. lbs., Step 2: 5915 ft. lbs
Exhaust Manifold to Cylinder Head Bolts — tightening sequence 1 stages
1install 8 new exhaust manifold stud9 ft. lbs
Intake Manifold to Engine Bolts — tightening sequence 1 stages
11.5 ft. lbs., Step 2: 181.5 ft. lbs

Factory maintenance schedule OEM · verified

Normal service, condensed from the factory interval matrix.

Under the factory schedule, replace the engine oil and filter every 7,500 mi; spark plugs every 97,500 mi; coolant every 45,000 mi. The big-interval services (every 45,000 mi for coolant, and the transmission fluid) are the ones owners most often skip — on a lower-mileage example, assume the original fluids are still in it and check them first.

At 7,500 miCabin Air Filter (inspect)
Every 7,500 miEngine Oil (drain & refill) · Engine Oil Filter (replace) · Tire & Wheel Assembly (rotate)
Every 15,000 miBrake System (inspect) · Cabin Air Filter (replace) · Cabin Air Filter (inspect) · Driveshaft U-Joint (inspect) · Engine Coolant System (inspect fluid level) · Exhaust System (Complete) (inspect)
Every 30,000 miEngine Air Filter Element (replace)
Every 45,000 miEngine Coolant System (drain, flush & refill)
Every 97,500 miSpark Plugs (replace)
At 105,000 miAccessory Drive Belt (inspect) · Engine Coolant System (drain, flush & refill)
At 150,000 miDrive Axle Assembly (drain & refill) · Drive Belt (replace) · Transmission Fluid & Filter (replace) · Wheel Bearing (replace)

Reliability & federal safety record

Owner-reported issues, recalls, investigations and service bulletins on record with NHTSA — an unfiltered look at what owners actually experience.

The 2012 Ford E‑250 sits near the midpoint of a decline in federal complaints, following a peak of 28 complaints in 1998 and a high of 30 TSBs that same year. 2012 recorded 8 complaints, 12 recalls, and no investigations, which is lower than the 2010–2011 average of 9–6 complaints and 12–18 recalls, indicating a modest improvement. The recall count in 2012 matches the 2013 level (12 recalls) but is well below the 2006 high of 30 recalls, suggesting a gradual reduction in recall frequency over the decade. Power‑train issues top the complaint list with three reports, while fire complaints are absent and crash complaints are minimal (one). Overall, the 2012 model year shows fewer complaints and recalls than earlier years, but still has a notable power‑train concern, implying it is a reasonable choice if that issue is addressed during purchase.

8
Open recalls
NHTSA campaigns
23
Service bulletins
Manufacturer communications
0
ODI investigations
Office of Defects Investigation
12
Owner complaints
1 involved a crash · 0 a fire
NHTSA crash-test rating federal NCAP · out of 5 stars
Rollover★★★★★
Owner complaints by model year NHTSA · this generation & adjacent

Owner complaints filed with NHTSA, by component

All 12 complaints on record, top 8 components.

Power Train3
Unknown Or Other,Forward Collision Avoidance1
Exterior Lighting,Seat Belts,Service Brakes1
Engine1
Electrical System,Seat Belts,Structure1
Structure1
Tires1
Steering,Suspension,Wheels1

Source: NHTSA Office of Defects Investigation complaint database.

Recalls NHTSA · verified

Showing 2 of 7 campaigns on record for this vehicle.

15V729000Equipment Adaptive/MobilityReported 04/11/2015

MobilityWorks (WMK Inc.) is recalling certain model year 2006-2014 Ford E-150, E-250, and E-350 vans modified by MobilityWorks to be equipped with certain model S2005, S2010, S5005, S5010, S5505, and S5510 wheelchair… Remedy: MobilityWorks will notify owners, and Ricon dealers will inspect the link arms for damage or for displaced bearings. The platform will be inspected for cracks. Any damaged parts…

14V097000Fuel System, Other:StorageReported 04/03/2014

Landi Renzo USA is recalling certain model year 2011-2014 Ford E-150, E-250, and E-350 vehicles modified January 2, 2011, through February 24, 2014 to operate on compressed natural gas (CNG). In the affected vehicles… Remedy: Landi Renzo USA will notify owners, and dealers will inspect and replace the side arm brackets, as necessary, free of charge. The recall began on March 27, 2014. Owners may…

Technical service bulletins NHTSA · verified

Showing 5 of 23 bulletins on record with NHTSA.

BulletinDateComponentSummary
SSM 546012026-02-23Electrical SystemFord and Lincoln vehicles equipped with wired keyless entry keypad systems and accessory…
SSM 530402024-10-10Unknown Or OtherWhile performing a transmission repair on some 2012-2024 Ford and Lincoln vehicles, a…
SSM 524762024-04-24EquipmentAll accessory stick-on keyless entry keypads come with a wallet card containing the…
SSM 481302019-08-09VisibilitySome 2010-2020 vehicles may exhibit distorted glass with a subtle orange peel pattern or…
SSM 481232019-08-07Electrical SystemFor Ford and Lincoln vehicles that require positive or negative battery terminal…

Common OBD-II trouble codes

The most common OBD-II codes for this vehicle's emissions system. These are standardized SAE J2012 definitions, not vehicle-specific fault reports.

P0420
Catalyst system efficiency below threshold — Bank 1
P0300
Random / multiple cylinder misfire detected
P0171
System too lean — Bank 1
P0455
Evaporative emission system leak detected — large leak
P0128
Coolant thermostat below regulating temperature
P0442
Evaporative emission system leak detected — small leak

VIN tools

Decode factory build data for a specific vehicle by VIN.

VIN
Decode a VIN to confirm the transmission and build data for a specific E. OEM
Build data
Plant, GVWR class, engine and body data for any 17-character VIN.
Recalls
Check open recall campaigns against a specific vehicle by VIN.

Vehicles with shared specs

Find every vehicle that shares this one's battery, bulbs, oil capacity, platform or parts.

Reference guides

Cross-vehicle references for the kinds of data on this page.

Frequently asked

How much oil does the 2012 E take?

6.0 qt of 5W-20 API MEETING FORD SPECIFICATION WSS-M2C945-A, per the factory manual.

Does the 2012 E have open recalls?

NHTSA lists 8 recall campaign(s) for this model year. Check your specific vehicle by VIN.