ChryslerTown and Country20092.8L/chrysler/town-and-country/2009/2-8l/
RT platform

2009 Chrysler Town and Country — 2.8L

Factory specifications, fluid capacities, torque values, EPA fuel economy and the federal safety record for the 2009 Town and Country 2.8L.

Body VANEngine 2.8L

The 2009 Chrysler Town and Country is a VAN built on the RT platform and powered by a 2.8L engine requiring 5.5 quarts of 10W-30 API oil. This model year brought 6 recalls and 706 owner complaints, with the Electrical System registering as the top concern. Within the model’s 1990–2018 complaint history, that total sits just below the 2011 peak of 773 and far above the 1990 low of 14, marking 2009 as a high-complaint year in the nameplate’s later production run.

Model year201320122011201020092008

Quick specs

Fluid capacities, tune-up values and fuel economy at a glance.

Engine oil capacity5.5 qtOEM · verified
Engine oil type10W-30 APIOEM · verified
Lug nut torque85-115 ft-lbsOEM · verified

Fitment & sizes

Replacement part sizes and factory part numbers — battery, bulbs, filters and belts.

From the factory this vehicle uses OE oil filter 04105409AE. Each part links to every other vehicle that shares it, so a part you already stock may fit more of your fleet than you'd expect.

Tire sizeP225-65R16OEM · verified
Wheel / rim6.5 inOEM · verified

OE service part numbers OEM · verified

Engine oil filter04105409AE
Engine air filter04891713AB
Spark plugSP303917AC alt SZFR5LP13G
BatteryBE031850AA alt BB34F101AA
Front wiper blades68028442AA alt 68125735AA
Thermostat68273161AA alt 04892307AA
Cabin air filter68606188AA

Full specifications

Engine, drivetrain, dimensions and economy.

Dimensions & weight NHTSA vPIC

Overall length202.4 in
Overall width76.8 in
Overall height68.9 in
Wheelbase121.3 in
Curb weight4621 lb
Track (front / rear)65 / 64.6 in
Weight distribution (front / rear)55/45

Service quick specs OEM factory data

Capacities, torques and tune-up values from the factory service manual.

This engine holds 5.5 qt of 10W-30 API engine oil, DOT 3 brake fluid. Torque lug nuts to 85-115 ft-lbs, the oil drain plug to 20.0 ft-lbs.

Lubricants & capacities

Automatic Transmission FluidATF+4
Automatic Transmission Fluid Capacity4
Brake FluidDOT 3
Engine Oil10W-30 · API · MS-6395
Engine Oil Capacity5.5 qt

Engine torques

Engine Flywheel Bolts65 ft-lbs
Engine Oil Pan Drain Plug20.0 ft-lbs
Oil Pump to Cylinder BLock Bolts/Studs21 ft-lbs

Chassis torques

Lug Nuts85-115 ft-lbs
Front Wheel Hub118 ft-lbs

Battery & A/C

RefrigerantR134a
Oil GroupPAG
Oil Type46

Service checks

Pressure Test15 psi
Radiator Cap Pressure Relief14-18 psi
Thermostat Opening Temperature192-199 °F
Intake Valve LashHydraulic in
Exhaust Valve LashHydraulic in

Brakes

Torque Caliper to Bracket26 ft-lbs
Torque to Knuckle125 ft-lbs / 74 ft-lbs
Minimum Pad ThicknessFront: 0.040; Rear: 0.040 in
Rotor Max Parallel Variation0.0004 in
Rotor Runout Limit0.002 in
Rotor Nominal Thickness From1.097 in / 0.463 in
Rotor Nominal Thickness To1.107 in / 0.482 in
Rotor Minimum Machining1.04 in / 0.409 in

Multi-step torque procedures OEM · verified

Connecting Rod (Large End) Bearings — tightening sequence 1 stages
15 ft. lbs., Step 2: 21 ft. lbs., Step 3: 905 ft. lbs
Cylinder Head — tightening sequence 4 stages
1Bolts 1 - 8 to 61 N##m (45 ft. lbs.)45 ft. lbs
2Bolts 1 - 8 to 88 N##m (65 ft. lbs.)65 ft. lbs
3Bolts 1 - 8 (again) to 88 N##m (65 ft. lbs.)65 ft. lbs
4Bolts 1 - 8 turn an additional 1/4 Turn. (Do not use a torque wrench for this step.)
Cylinder Head — tightening sequence 1 stages
145.0 ft. lbs. Step 2: 65.0 ft. lbs. Step 3: 65.0 ft. lbs. Step 4: 90 degreesCAUTION:Do not use a torque wrench for the Fourth step. Bolts should be checked for stretching using a straight edge. Ay bolts that show stretching should be replaced.45 ft. lbs
Main Bearings — tightening sequence 1 stages
130 ft. lbs., Step 2: 9030 ft. lbs

Factory maintenance schedule OEM · verified

Normal service, condensed from the factory interval matrix.

Under the factory schedule, replace the engine oil and filter every 6,000 mi; coolant at 102,000 mi. The big-interval services (at 102,000 mi for coolant, and the transmission fluid) are the ones owners most often skip — on a lower-mileage example, assume the original fluids are still in it and check them first.

Every 6,000 miBrake Line (inspect) · Engine Oil (drain & refill) · Engine Oil Filter (replace) · Tire & Wheel Assembly (rotate)
At 12,000 miCV Joint Boot (inspect) · Exhaust System (Complete) (inspect)
Every 12,000 miBrake Linings (inspect) · Cabin Air Filter (replace)
Every 24,000 miCV Joint Boot (inspect) · Exhaust System (Complete) (inspect) · Steering Linkage (inspect) · Suspension System (inspect)
Every 30,000 miEngine Air Filter Element (replace)
Every 90,000 miPCV Valve (inspect)
At 102,000 miEngine Coolant System (drain, flush & refill)
At 120,000 miDrive Belt (replace) · Transmission Fluid & Filter (replace)

Owner how-tos

Condensed service procedures for routine maintenance. Procedures that require dealer diagnostic equipment are identified and summarized only.

Common procedures

Key fob — remote (RKE) programming programming new fob buttons Dealer tool OEM · verified
Tool requiredDRBIII scan tool (dealer / locksmith)
WhyTransmitter codes are written into the receiver in the passenger door module
Anti-theft (SKIS) — module initialization after immobilizer module replacement Dealer tool OEM · verified
When neededAfter Sentry Key Immobilizer Module (SKIM) replacement
Tool requiredDRBIII scan tool
Also requiredThe vehicle's four-digit PIN code

Reliability & federal safety record

Owner-reported issues, recalls, investigations and service bulletins on record with NHTSA — an unfiltered look at what owners actually experience.

The 2009 Chrysler Town and Country marks a peak in complaints within its generation, with 773 reported—significantly higher than the 473 in 2001 and the 631–679 range seen in 2012–2014, though slightly below the 2011 total. This year also saw three recalls and three investigations, aligning with the mid-cycle average but reflecting persistent issues, particularly in the electrical system (208 complaints) and air bags (156 combined). The data shows a clear upward trend in complaints from 2001 through 2011, followed by a gradual decline, suggesting 2009 falls in the problematic heart of this arc. Crash (11) and fire (12) complaints, while not negligible, are less pronounced than broader electrical or safety concerns. The concentration of recalls and investigations in this period implies systemic rather than isolated flaws. **Takeaway:** The 2009 model year is a high-risk choice due to its elevated complaint volume and unresolved electrical/safety issues—avoid unless thorough pre-purchase inspection and service records confirm these problems were addressed.**

6
Open recalls
NHTSA campaigns
83
Service bulletins
Manufacturer communications
2
ODI investigations
Office of Defects Investigation
706
Owner complaints
11 involved a crash · 12 a fire
Owner complaints by model year NHTSA · this generation & adjacent

Owner complaints filed with NHTSA, by component

All 706 complaints on record, top 8 components.

Electrical System208
Electrical System,Air Bags156
Engine36
Service Brakes25
Unknown Or Other20
Service Brakes, Hydraulic19
Wheels18
Air Bags18

Source: NHTSA Office of Defects Investigation complaint database.

Recalls NHTSA · verified

No recall campaigns on record with NHTSA for this vehicle as of the last data refresh.

Technical service bulletins NHTSA · verified

Showing 5 of 83 bulletins on record with NHTSA.

BulletinDateComponentSummary
1084632025-11-18Service BrakesPAD KIT - REAR DISC BRAKE, FRONT DISC BRAKE
1084642025-11-17Service BrakesPAD KIT - REAR DISC BRAKE, FRONT DISC BRAKE
91002262023-09-15Electrical SystemConnector kit Before ordering this connector repair kit 68018957A$, check it in the Mopar…
91002262023-09-15Electrical SystemConnector kit Before ordering this connector repair kit 68018957A$, check it in the Mopar…
Y22 Combo Rev12021-11-23Air BagsCustomer Satisfaction Notification Y22 Driver Airbag Emblem

Common OBD-II trouble codes

The most common OBD-II codes for this vehicle's emissions system. These are standardized SAE J2012 definitions, not vehicle-specific fault reports.

P0420
Catalyst system efficiency below threshold — Bank 1
P0300
Random / multiple cylinder misfire detected
P0171
System too lean — Bank 1
P0455
Evaporative emission system leak detected — large leak
P0128
Coolant thermostat below regulating temperature
P0442
Evaporative emission system leak detected — small leak

VIN tools

Decode factory build data for a specific vehicle by VIN.

VIN
Decode a VIN to confirm the transmission and build data for a specific Town and Country. OEM
Build data
Plant, GVWR class, engine and body data for any 17-character VIN.
Recalls
Check open recall campaigns against a specific vehicle by VIN.

Vehicles with shared specs

Find every vehicle that shares this one's battery, bulbs, oil capacity, platform or parts.

Reference guides

Cross-vehicle references for the kinds of data on this page.

Frequently asked

How much oil does the 2009 Town and Country 2.8L take?

5.5 qt of 10W-30 API MEETING CHRYSLER SPECIFICATION MS-6395, per the factory manual.

Does the 2009 Town and Country have open recalls?

NHTSA lists 6 recall campaign(s) for this model year. Check your specific vehicle by VIN.