Chevrolet›Lumina›2000›Overview/chevrolet/lumina/2000/base/

2000 Chevrolet Lumina

Factory specifications, fluid capacities, torque values, EPA fuel economy and the federal safety record for the 2000 Lumina.

Body PASSENGER CAR

The 2000 Chevrolet Lumina is a passenger car that requires 4.5 quarts of 5W-30 API oil for its engine service. This model year recorded 41 owner complaints, with engine and engine cooling issues representing the most frequently reported problem area, and the vehicle was subject to six recalls during its lifecycle. Compared to the model's complaint history spanning 1990 to 2008, where complaints peaked at 584 in 1995 and dropped to just 1 by 2008, the 2000 Lumina falls toward the lower end of the complaint spectrum, suggesting a period of improving reliability as the model matured.

Model year2001 2000 1999 1998 1997 1996 1995 1994 1993

Quick specs

Fluid capacities, tune-up values and fuel economy at a glance.

Engine oil capacity4.5 qtOEM · verified

Engine oil type5W-30 APIOEM · verified

Lug nut torque100 ft-lbsOEM · verified

Fitment & sizes

Replacement part sizes and factory part numbers — battery, bulbs, filters and belts.

From the factory this vehicle uses a BCI 78 · 600 CCA battery, OE oil filter 12731175. Each part links to every other vehicle that shares it, so a part you already stock may fit more of your fleet than you'd expect.

Battery groupBCI 78 · 600 CCAOEM · verified

Tire sizeP225/60R16OEM · verified

OE service part numbers OEM · verified

Engine oil filter	12731175 alt 25322835
Engine air filter	19166106
Spark plug	19301813
Front wiper blades	15214346
Thermostat	10226107 alt 24507563

Performance & power Independent road tests

0–60 mph, quarter-mile, horsepower and torque from independent road tests.

Independent road tests for the Lumina of this era, listed by trim and engine — this page spans more than one engine, so no single horsepower figure is shown.

7.1–9.8 sec0–60 mph (tested)quickest 7.10 sec — 1991 Z34 Coupe

Year	Trim / engine	0–60	¼ mile	HP	Drivetrain
1998	LTZ Sedan 3.8L V6	7.60 sec	15.80 sec	200 hp	FWD
1995	LS Sedan 3.4L V6	8.40 sec	16.30 sec	160 hp	FWD
1995	Sedan 3.1L V6	9.50 sec	17.00 sec	160 hp	FWD
1991	Z34 Coupe 3.4L V6	7.10 sec	15.50 sec	210 hp	FWD
1990	Euro Sedan 3.1L V6	9.80 sec	17.90 sec	140 hp	FWD

Service quick specs OEM factory data

Capacities, torques and tune-up values from the factory service manual.

This engine holds 4.5 qt of 5W-30 API engine oil. Torque lug nuts to 100 ft-lbs, the oil drain plug to 18.0 ft-lbs. The firing order is 1-2-3-4-5-6.

Lubricants & capacities

Engine Oil	5W-30 · API
Engine Oil Capacity	4.5 qt

Engine torques

Exhaust Manifold to Cylinder Head Bolts	12 ft-lbs
Engine Oil Pan Drain Plug	18.0 ft-lbs
Engine Valve Cover Bolts	7.4 ft-lbs

Chassis torques

Lug Nuts	100 ft-lbs
Front Wheel Hub	159 ft-lbs

Ignition

Cylinder Firing Order	1-2-3-4-5-6
Ignition Coil Secondary Resistance	5000-7000 ohms
Spark Plug Manufacturer	AC Delco
Spark Plug Gap	0.060 in
Spark Plug Torque	11.0 ft-lbs

Battery & A/C

Refrigerant	R134a
Refrigerant Capacity	1.85-1.00 lbs
Oil Group	PAG
Oil Type	GM part number 12345923 or equivalent.
Oil Capacity	8.00-9.00 oz
Standard BCI Group Number	78
Standard BCI Cranking Performance	600 cca

Service checks

Pressure Test	15, Pressure should not exceed 20 psi.
Radiator Cap Pressure Relief	15 psi
Thermostat Opening Temperature	188-206 °F
Fuel Pump Pressure Minimum	59.0 psi
Key ON Engine OFF (KOEO)	52-59
RPM	42-56 @ Idle rpm
Injector Primary Resistance	11.4-12.6 @ 50-95 degreesF ohms
Engine Compression	100

Brakes

Torque Caliper to Bracket	137 ft-lbs / 33 ft-lbs
Torque to Knuckle	100 ft-lbs / 92 ft-lbs
Minimum Pad Thickness	Front: 0.030; Rear: 0.030 specification
Rotor Max Parallel Variation	0.0005 in
Rotor Runout Limit	0.003 in
Rotor Nominal Thickness From	1.039 in / 0.433 in
Rotor Nominal Thickness To	1.039 in / 0.433 in
Rotor Minimum Machining	0.987 in / 0.385 in

Multi-step torque procedures OEM · verified

Cylinder Head — tightening sequence 2 stages

1	44 ft. lbs.	44 ft. lbs
2	95

Factory maintenance schedule OEM · verified

Normal service, condensed from the factory interval matrix.

Under the factory schedule, replace the engine oil and filter every 7,500 mi; spark plugs every 100,000 mi; coolant at 150,000 mi. The big-interval services (at 150,000 mi for coolant, and the transmission fluid) are the ones owners most often skip — on a lower-mileage example, assume the original fluids are still in it and check them first.

Every 7,500 mi	Engine Oil (drain & refill) · Engine Oil Filter (replace) · Tire & Wheel Assembly (rotate)
At 15,000 mi	Engine Air Filter Element (inspect)
Every 30,000 mi	Engine Air Filter Element (inspect) · Engine Air Filter Element (replace)
Every 60,000 mi	Accessory Drive Belt (inspect)
Every 100,000 mi	Spark Plug Wires (inspect) · Spark Plugs (replace) · Transmission Fluid & Filter (replace)
At 150,000 mi	Engine Coolant System (drain, flush & refill)

Reliability & federal safety record

Owner-reported issues, recalls, investigations and service bulletins on record with NHTSA — an unfiltered look at what owners actually experience.

Across the generation, owner complaints trended downward from the high-volume early 1990s, with a notable 1995 spike of 584 complaints before a steady decline through 1999–2001. The 2000 model sits near the bottom of that complaint curve at just 41 complaints, yet it carries a comparatively high recall count of six—more than the 1999 (3) and 2001 (4) models—and a dramatic TSB surge to 255 bulletins versus 80 in 1999. Top complaint categories for 2000 were Engine & Engine Cooling (7), Power Train (6), Electrical System (5), and Service Brakes, Hydraulic (4), with two crash-related and one fire-related complaint on file; the data does not specify root causes. The TSB spike continues into 2001 (275) before dropping, suggesting 2000–2001 represent a late-model service-intensity phase rather than a broad reliability failure. Given the very low complaint volume but elevated recalls and TSBs, the 2000 Lumina is a reasonable used-car candidate provided a buyer verifies all recalls were addressed and reviews service history for engine, electrical, and brake work.

Open recalls

NHTSA campaigns

255

Service bulletins

Manufacturer communications

ODI investigations

Office of Defects Investigation

Owner complaints

2 involved a crash · 1 a fire

NHTSA crash-test rating federal NCAP · out of 5 stars

Rollover★★★★★

Owner complaints by model year NHTSA · this generation & adjacent

’90 ’91 ’92 ’93 ’94 ’95 ’96 ’97 ’98 ’99’00’01 ’02 ’08

Owner complaints filed with NHTSA, by component

All 41 complaints on record, top 8 components.

Engine & Engine Cooling7

Power Train6

Electrical System5

Service Brakes, Hydraulic4

Steering3

Tires2

Structure2

Wheels,Engine1

Source: NHTSA Office of Defects Investigation complaint database.

Recalls NHTSA · verified

Showing 2 of 6 campaigns on record for this vehicle.

99V357000Service Brakes, Hydraulic:Foundation Components:Hoses, Lines/Piping, And FittingsReported 17/12/1999

VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE RIGHT FRONT BRAKE HOSE IS INCORRECTLY ROUTED BEHIND THE BRAKE PIPE BRACKET RESTRICTING BRAKE HOSE MOVEMENT THAT COULD CAUSE THE HOSE TO EITHER BE CUT BY THE BRACKET OR… Remedy: DEALERS WILL REPLACE AND CORRECTLY ROUTE THE RIGHT FRONT BRAKE HOSE ASSEMBLY.

07E021000Fuel System, Other:Storage:Tank Assembly:Pressure Relief DevicesReported 12/03/2007

CERTAIN DELPHI FUEL PRESSURE REGULATORS, P/NOS. FP10020-11B1, FP10026-11B1, AND FP10027-11B1, SOLD AFTER JANUARY 9, 2007, AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES LISTED ABOVE. THE UNIVERSAL PRESSURE… Remedy: DELPHI WILL NOTIFY OWNERS AND REPLACE THE UPR FREE OF CHARGE. THE RECALL BEGAN ON APRIL 23, 2007. OWNERS CAN CONTACT DELPHI AT 877-411-8770.

Technical service bulletins NHTSA · verified

Showing 5 of 255 bulletins on record with NHTSA.

Bulletin	Date	Component	Summary
PIP4723J	2024-10-25	Electrical System	This Preliminary Information communicates to the dealer the process for downloading or…
PIT5099H	2024-09-12	Unknown Or Other	This Preliminary Information communication provides information to the technician about…
PIT5099H	2024-09-12	Unknown Or Other	This Preliminary Information communication provides information to the technician about…
General Communication	2024-08-26	Electrical System	Vehicle Wide Programming (VWP) is a new process to update software on GM Vehicles. It…
24-NA-141	2024-07-24	Power Train	GM is receiving damaged (cracked or broken) transmission cores returned to the reman…

Common OBD-II trouble codes

The most common OBD-II codes for this vehicle's emissions system. These are standardized SAE J2012 definitions, not vehicle-specific fault reports.

P0420

Catalyst system efficiency below threshold — Bank 1

P0300

Random / multiple cylinder misfire detected

P0171

System too lean — Bank 1

P0455

Evaporative emission system leak detected — large leak

P0128

Coolant thermostat below regulating temperature

P0442

Evaporative emission system leak detected — small leak

VIN tools

Decode factory build data for a specific vehicle by VIN.

VIN

Decode a VIN to confirm the transmission and build data for a specific Lumina. OEM

Build data

Plant, GVWR class, engine and body data for any 17-character VIN.

Recalls

Check open recall campaigns against a specific vehicle by VIN.

Vehicles with shared specs

Find every vehicle that shares this one's battery, bulbs, oil capacity, platform or parts.

Group 78 battery Vehicles taking 4.5 qt Engine oil filter 12731175 Engine air filter 19166106 Spark plug 19301813 Front wiper blades 15214346

Reference guides

Cross-vehicle references for the kinds of data on this page.

Vehicle recalls & TSBs OBD-II trouble codes Torque specifications Maintenance schedules Fluid capacities & specs

Frequently asked

How much oil does the 2000 Lumina take?

4.5 qt of 5W-30 API, per the factory manual.

Does the 2000 Lumina have open recalls?

NHTSA lists 6 recall campaign(s) for this model year. Check your specific vehicle by VIN.