Factory specifications, fluid capacities, torque values, EPA fuel economy and the federal safety record for the 2016 650i.
The 2016 BMW 650i is the automatic S8-equipped iteration of the 6 Series line, carrying an EPA rating of 17/25/20 mpg and, in owner-reported data, a light reliability footprint of six total complaints and one recall. With the engine cited as the top complaint area, it is the specific subsystem worth watching for researchers examining this model year. Compared with the preceding 2012–2015 run, which peaked at 22 complaints in 2012 and fell to just three by 2015, the 2016 figure continues that low-complaint trajectory, meaning the 650i enters this year on a relatively quiet reliability note even as the engine category remains the dominant concern.
Fluid capacities, tune-up values and fuel economy at a glance.
Replacement part sizes and factory part numbers — battery, bulbs, filters and belts.
From the factory this vehicle uses a BCI 95R · 950 CCA battery, OE oil filter 11427583220. Each part links to every other vehicle that shares it, so a part you already stock may fit more of your fleet than you'd expect.
| Engine oil filter | 11427583220 |
| Engine air filter | 13717577457 alt 13717577458 |
| Spark plug | 12120040581 |
| Battery | 61215A40E29 alt 61215A40E33 |
| Front wiper blades | 61612458020 |
| Thermostat | 11538632664 alt 11537586885 |
| Cabin air filter | 64119272642 alt 64116809933 |
Engine, drivetrain, dimensions and economy.
| Transmission | Automatic (S8) |
| Overall length | 192.5 in |
| Overall width | 74.4 in |
| Overall height | 53.9 in |
| Wheelbase | 112.6 in |
| Curb weight | 4409 lb |
| Track (front / rear) | 63 / 65.7 in |
| Weight distribution (front / rear) | 54/46 |
| EPA city / highway / combined | 17 / 25 / 20 mpg |
| Drivetrain | Rear-Wheel Drive |
| Recommended fuel | Premium Gasoline |
0–60 mph, quarter-mile, horsepower and torque from independent road tests.
Independent road tests for the 650i of this era, listed by trim and engine — this page spans more than one engine, so no single horsepower figure is shown.
| Year | Trim / engine | 0–60 | ¼ mile | HP | Drivetrain |
|---|---|---|---|---|---|
| 2016 | Coupe 4.4L Twin-Turbo V8 | 4.10 sec | 12.60 sec | 445 hp | RWD |
| 2013 | xDrive Gran Coupe 4.4L Twin-Turbo V8 | 4.20 sec | 12.70 sec | 445 hp | AWD |
| 2013 | Gran Coupe 4.4L Twin-Turbo V8 | 4.60 sec | 13.00 sec | 445 hp | RWD |
| 2013 | xDrive Gran Coupe 4.4L Twin-Turbo V8 | 4.60 sec | 12.90 sec | 445 hp | AWD |
| 2012 | xDrive Convertible 4.4L Twin-Turbo V8 | 4.40 sec | 12.90 sec | 400 hp | AWD |
| 2012 | Coupe 4.4L Twin-Turbo V8 | 4.50 sec | 12.90 sec | 400 hp | RWD |
| 2012 | Convertible 4.4L Twin-Turbo V8 | 4.60 sec | 13.00 sec | 400 hp | RWD |
| 2012 | Convertible 4.4L Twin-Turbo V8 | 4.70 sec | 13.10 sec | 400 hp | RWD |
Capacities, torques and tune-up values from the factory service manual.
This engine synthetic in the differential, DOT 4 brake fluid. Torque the oil drain plug to M12 Bolts: 18.0, M22 Bolts: 44.0 ft-lbs. The firing order is 1-5-4-8-6-3-7-2. Note the cylinder-head bolts finish on a torque angle (torque-to-yield) — they stretch permanently and should be replaced, not reused, during any head service.
| Brake Fluid | DOT 4 |
| Clutch Fluid | DOT 4 |
| Differential Gear Oil | synthetic |
| Differential Gear Oil Capacity | 1.2-3.0 |
| Manual Transmission Fluid Capacity | 3.0-3.2 |
| Manual Transmission Fluid Capacity | 2.5-3.2 |
| Manual Transmission Fluid | BMW MTF-LT-5 |
| Manual Transmission Fluid Capacity | 2.5-3.0 |
| Intake Manifold to Engine Bolts | 11 |
| Engine Oil Pan Drain Plug | M12 Bolts: 18.0, M22 Bolts: 44.0 ft-lbs |
| Driveshaft Flange to Transmission | M8 Bolts: 33.0, M10: 58.0 ft-lbs |
| Cylinder Firing Order | 1-5-4-8-6-3-7-2 |
| Spark Plug Manufacturer | BMW |
| Spark Plug Type | M14X1.25 |
| Spark Plug Gap | non-adjustable in |
| Spark Plug Torque | 20.0 - 24.3 ft-lbs |
| Refrigerant | R134a |
| Oil Group | PAG |
| Oil Type | 46 |
| Standard BCI Group Number | 95R |
| Standard BCI Cranking Performance | 950 cca |
| Pressure Test | 21.7 psi |
| Radiator Cap Pressure Relief | 28-32 psi |
| Minimum Pad Thickness | Front: 0.145; Rear: 0.145 pads |
| Vented Rotor Minimum Thickness for Replacement | Stamped on rotor |
Prep Do not reuse old bolts
| 1 | 22.0 ft. lbs. | 22 ft. lbs |
| 2 | 90 degrees | 90 degrees |
| 3 | 90 degrees | 90 degrees |
Owner-reported issues, recalls, investigations and service bulletins on record with NHTSA — an unfiltered look at what owners actually experience.
From 2012 to 2015, complaints fell steadily from 22 to 3 while recalls varied between zero and one per year. In 2016 the recorded complaint areas show 3 engine‑related, 2 power‑train/engine, and 1 power‑train/engine/fuel‑propulsion issue, with zero crash or fire complaints. The total of six complaint counts in 2016 matches the 2014 level and is higher than the 2015 low but far below the 2012‑2013 peaks. No recall, investigation or TSB figures are supplied for 2016, so the recall trend cannot be extended to that year. Given the low complaint volume and absence of crash/fire reports, the 2016 BMW 650i appears to be a reliable used‑car option within the generation.
All 6 complaints on record, top 3 components.
Source: NHTSA Office of Defects Investigation complaint database.
Showing 1 of 1 campaigns on record for this vehicle.
BMW of North America, LLC (BMW) is recalling certain 2013-2018 BMW C600 Sport and C650 Sport and 2013-2019 C650 GT scooters. Repeated turning of the handlebars to the left most position may cause the front brake hose to… Remedy: BMW will notify owners, and dealers will replace the brake hose, adding an additional protective sleeve that will cover the hose connection fitting, free of charge. The recall…
Showing 5 of 23 bulletins on record with NHTSA.
| Bulletin | Date | Component | Summary |
|---|---|---|---|
| B611305 | 2024-01-11 | Electrical System | The electrical system of BMW vehicles has been subject to an ongoing development process… |
| MC310421 | 2021-04-01 | Structure | The complaint of leaking telescopic forks is the top warranty claim in many current… |
| MC64481126 | 2021-04-01 | Electrical System | SVA! infotext is displayed in instrument cluster (see attachment) |
| MC64010520 | 2018-01-29 | Electrical System | Incorrect tire pressure appears in the instrument cluster. Contamination or obstruction… |
| MC63997656 | 2018-01-18 | Electrical System | Instrument cluster self check is slow. Suftware update is required. Rectified with I… |
The most common OBD-II codes for this vehicle's emissions system. These are standardized SAE J2012 definitions, not vehicle-specific fault reports.
Decode factory build data for a specific vehicle by VIN.
Find every vehicle that shares this one's battery, bulbs, oil capacity, platform or parts.
Cross-vehicle references for the kinds of data on this page.
Refer to the appropriate Motologic service procedures for drain and refill procedure. of Use engine oil meeting BMW specification LL-01 or equivalent., per the factory manual.
NHTSA lists 1 recall campaign(s) for this model year. Check your specific vehicle by VIN.
EPA figures are 17 city / 25 highway / 20 combined mpg.