AudiTT/TTS Coupe/Roadster2010Overview/audi/tt-tts-coupe-roadster/2010/base/

2010 Audi TT/TTS Coupe/Roadster

Factory specifications, fluid capacities, torque values, EPA fuel economy and the federal safety record for the 2010 TT/TTS Coupe/Roadster.

Body PASSENGER CARTransmission Automatic (S6)

The 2010 Audi TT/TTS Coupe/Roadster is a passenger car powered by an engine requiring 4.8 quarts of 5W-30/5W-40 API oil, paired with an Automatic (S6) transmission and EPA-rated at 21/29/24 mpg. In the model’s reliability record, this year shows just four owner complaints and a single recall, with the Power Train area drawing the most reports. That points to a comparatively low-complaint model year, though researchers should still weigh the small powertrain issue share against the limited overall reporting volume.

Model year201220112010200920062005200420032002

Quick specs

Fluid capacities, tune-up values and fuel economy at a glance.

Engine oil capacity4.8 qtOEM · verified
Engine oil type5W-30 / 5W-40 APIOEM · verified
Lug nut torque89 ft-lbsOEM · verified
EPA fuel economy21/29/24 mpgEPA · verified

Fitment & sizes

Replacement part sizes and factory part numbers — battery, bulbs, filters and belts.

From the factory this vehicle uses a BCI 47 · 480 CCA battery, OE oil filter 06J115403Q. Each part links to every other vehicle that shares it, so a part you already stock may fit more of your fleet than you'd expect.

Battery groupBCI 47 · 480 CCAOEM · verified
Tire sizeP245-40R18OEM · verified

OE service part numbers OEM · verified

Engine oil filter06J115403Q
Engine air filter1K0129620G
Fuel filter1K0201051K
Spark plug06H905601A
Battery000915089BD alt 000915089G
Front wiper blades8J1955426C alt 8J1955425C
Serpentine belt06J260849D
Thermostat06H121113B alt 06H121119E
Cabin air filter1K1819669

Full specifications

Engine, drivetrain, dimensions and economy.

Engine & drivetrain NHTSA vPIC

TransmissionAutomatic (S6)

Ratings & economy EPA / vPIC

EPA city / highway / combined21 / 29 / 24 mpg
DrivetrainAll-Wheel Drive
Recommended fuelPremium Gasoline

Service quick specs OEM factory data

Capacities, torques and tune-up values from the factory service manual.

This engine holds 4.8 qt of 5W-30 / 5W-40 API engine oil, 75W-90 · GL-4 in the differential. Torque lug nuts to 89 ft-lbs, the oil drain plug to 18.4 ft-lbs. The firing order is 1-3-4-2. Note the cylinder-head bolts finish on a torque angle (torque-to-yield) — they stretch permanently and should be replaced, not reused, during any head service.

Lubricants & capacities

Differential Gear Oil75W-90 · GL-4
Differential Gear Oil Capacity2 Pints
Engine Oil5W-30 · 5W-40 · API
Engine Oil Capacity4.8 qt
Power Steering FluidUSE AUDI PART NO. G002000 OR G004000

Engine torques

Intake Manifold to Engine Bolts7.3 ft-lbs
Intake Manifold to Engine Bolts6.6 ft-lbs
Exhaust Manifold to Cylinder Head Bolts15.5 ft-lbs
Engine Oil Pan Drain Plug18.4 ft-lbs
Oil Pump to Cylinder BLock Bolts/Studs17 ft-lbs
Engine Valve Cover Bolts7.2

Chassis torques

Lug Nuts89 ft-lbs
Transfer Case Fill Plug11.0 ft-lbs
Transfer Case Drain PlugBevel box: 44.0, Haldex Clutch: 22.0 ft-lbs

Ignition

Cylinder Firing Order1-3-4-2
Spark Plug ManufacturerAudi/VW
Spark Plug Torque22 ft-lbs
Spark Plug Torque22.0 ft-lbs

Battery & A/C

RefrigerantR134a
Oil GroupPAG
Standard BCI Group Number47
Standard BCI Cranking Performance480 cca

Service checks

Pressure Test14.5 psi
Radiator Cap Pressure Relief20-23 psi
Thermostat Opening Temperature188 °F
Engine Compression159-203 PSI @ RPM. 44 maximum variation PSI.

Brakes

Brake ApplicationWITH 16 inch ROTOR / WITH 17 inch ROTOR
Torque Caliper to Bracket26 ft-lbs
Brake ApplicationWITH FN3
Torque Caliper to Bracket22 ft-lbs
Torque to Knuckle148 USE NEW BOLTS ONLY ft-lbs
Brake ApplicationWITH 16 inch ROTOR / WITH 17 inch ROTOR
Rotor Nominal Thickness From0.472 in / 0.866 in
Rotor Nominal Thickness To0.472 in / 0.866 in

Multi-step torque procedures OEM · verified

Torque to Knuckle — tightening sequence 1 stages
190
Camshaft Bearing/Carrier Cap Bolts or Studs — tightening sequence 1 stages
16 ft. lbs., Step 2: 906 ft. lbs
Connecting Rod (Large End) Bearings — tightening sequence 1 stages
133 ft. lbs., Step 2: 9033 ft. lbs
Crankshaft Pulley and/or Damper Bolts — tightening sequence 1 stages
1150 ft. lbs., step 2: 90150 ft. lbs
Cylinder Head — tightening sequence 5 stages

Prep Do not reuse old bolts. Use new bolts coated with clean engine oil. Tighten all bolts to finger tight then continue on with the following procedure.

129.5 ft. lbs.29.5 ft. lbs
237.0 ft. lbs37 ft. lbs
3180 degrees180 degrees
4crankcase vent bolt pretighten to 6.0 ft. lbs.6 ft. lbs
590 degrees90 degrees
Engine Flywheel Bolts — tightening sequence 1 stages
144 ft. lbs., Step 2: 9044 ft. lbs
Exhaust Manifold to Cylinder Head Bolts — tightening sequence 1 stages
14 ft. lbs., step 2: 9 ft. lbs., step 3: 12 ft. lbs., step 4: step 184 ft. lbs

Factory maintenance schedule OEM · verified

Normal service, condensed from the factory interval matrix.

Under the factory schedule, replace the engine oil and filter at 5,000 mi; coolant at 15,000 mi. The big-interval services (at 15,000 mi for coolant, and the transmission fluid) are the ones owners most often skip — on a lower-mileage example, assume the original fluids are still in it and check them first.

At 5,000 miBrake System (inspect) · Engine Oil (drain & refill) · Engine Oil Filter (replace) · Headlamp Washer Nozzle (inspect) · Headlamp Washer System (inspect fluid level) · Tire & Wheel Assembly (rotate)
Every 10,000 miBrake System (inspect) · Engine Oil (drain & refill) · Engine Oil Filter (replace) · Headlamp Washer Nozzle (inspect) · Headlamp Washer System (inspect fluid level) · Tire & Wheel Assembly (inspect)
At 15,000 miAir Conditioning Evaporator Case Drain (inspect) · Battery (inspect) · CV Joint Boot (inspect) · Cabin Air Filter (replace) · Engine Assembly (leak inspection) · Engine Coolant System (inspect fluid level)
Every 20,000 miAir Conditioning Evaporator Case Drain (inspect) · Battery (inspect) · CV Joint Boot (inspect) · Cabin Air Filter (replace) · Engine Assembly (leak inspection) · Engine Coolant System (inspect fluid level)
At 35,000 miBrake Rotor (inspect) · Door Stop (lubricate) · Drive Axle Assembly (inspect) · Exterior Lighting (inspect) · Hood Latch (lubricate) · Power Steering System (inspect fluid level)
Every 40,000 miBrake Rotor (inspect) · Door Stop (lubricate) · Drive Axle Assembly (inspect) · Exterior Lighting (inspect) · Hood Latch (lubricate) · Power Steering System (inspect fluid level)
At 55,000 miEngine Air Filter Element (replace) · Engine Air Filter Housing (clean)
Every 60,000 miEngine Air Filter Element (replace) · Engine Air Filter Housing (clean)
At 75,000 miAccessory Drive Belt (inspect)

Reliability & federal safety record

Owner-reported issues, recalls, investigations and service bulletins on record with NHTSA — an unfiltered look at what owners actually experience.

Owner complaints about the 2010 Audi TT/TTS Coupe/Roadster dominate in one area — the power train, 4 of 4 reports (100%), well ahead of the next concern. None of this vehicle's 1 recall campaigns target the power train, so those reports read as owner-reported wear-and-tear rather than an acknowledged defect. 0 of the reports describe a crash and 0 a fire — a small share of the total, but worth weighing against the power train pattern above. These are tallies of what owners actually reported to the federal government, not an editorial score — and higher-selling models naturally rack up more reports.

1
Open recalls
NHTSA campaigns
596
Service bulletins
Manufacturer communications
1
ODI investigations
Office of Defects Investigation
4
Owner complaints
0 involved a crash · 0 a fire
NHTSA crash-test rating federal NCAP · out of 5 stars
Rollover★★★★

Owner complaints filed with NHTSA, by component

All 4 complaints on record, top 1 components.

Power Train4

Source: NHTSA Office of Defects Investigation complaint database.

Recalls NHTSA · verified

Showing 1 of 1 campaigns on record for this vehicle.

09V377000Fuel System, Gasoline:Storage:Tank AssemblyReported 30/09/2009

VOLKSWAGEN IS RECALLING CERTAIN MODEL YEAR 2006 THROUGH 2010 AUDI A3, TT, AND TT ROADSTER PASSENGER VEHICLES MANUFACTURED BETWEEN SEPTEMBER 29, 2005 AND AUGUST 26, 2009. THE CLOSING FORCE OF AN INTERNAL SPRING OF THE… Remedy: VOLKSWAGEN WILL NOTIFY OWNERS AND AUDI DEALERS WILL REPLACE THE FUEL TANK VENTILATION VALVE WITH AN IMPROVED VALVE FREE OF CHARGE. THE SAFETY RECALL BEGAN ON NOVEMBER 16, 2009…

Technical service bulletins NHTSA · verified

Showing 5 of 596 bulletins on record with NHTSA.

BulletinDateComponentSummary
TSB_2070568_62026-04-22Unknown Or OtherThis bulletin provides information about professional noise analysis with the VAS 611 015…
TSB_2024323_132026-03-17Electrical SystemThis bulletin provides information when the parking assistance gives false warnings.
TSB_2024323_122026-03-02Electrical SystemThis bulletin provides information when the parking assistance gives false warnings.
TSB_2060750_52026-01-14EngineThis bulletin provides information regarding UV leak additive for finding oil leaks.
TSB_2074846_42026-01-13SteeringThis bulletin provides information about vibrations and rotational steering vibrations.

Common OBD-II trouble codes

The most common OBD-II codes for this vehicle's emissions system. These are standardized SAE J2012 definitions, not vehicle-specific fault reports.

P0420
Catalyst system efficiency below threshold — Bank 1
P0300
Random / multiple cylinder misfire detected
P0171
System too lean — Bank 1
P0455
Evaporative emission system leak detected — large leak
P0128
Coolant thermostat below regulating temperature
P0442
Evaporative emission system leak detected — small leak

VIN tools

Decode factory build data for a specific vehicle by VIN.

VIN
Decode a VIN to confirm the transmission and build data for a specific TT/TTS Coupe/Roadster. OEM
Build data
Plant, GVWR class, engine and body data for any 17-character VIN.
Recalls
Check open recall campaigns against a specific vehicle by VIN.

Vehicles with shared specs

Find every vehicle that shares this one's battery, bulbs, oil capacity, platform or parts.

Reference guides

Cross-vehicle references for the kinds of data on this page.

Frequently asked

How much oil does the 2010 TT/TTS Coupe/Roadster take?

4.8 qt of 5W-30 OR 5W-40 API MEETING VW SPECIFICATION VW50200, per the factory manual.

Does the 2010 TT/TTS Coupe/Roadster have open recalls?

NHTSA lists 1 recall campaign(s) for this model year. Check your specific vehicle by VIN.

What gas mileage does the TT/TTS Coupe/Roadster get?

EPA figures are 21 city / 29 highway / 24 combined mpg.